INEOS Grenadier recalls

4 official safety recalls for the INEOS Grenadier from NHTSA (United States), DVSA (United Kingdom) and the EU Safety Gate, newest first. Recall repairs are normally free at the maker’s dealers.

Whether your car is affected and still needs the repair depends on its VIN or registration. Check it on the official site for your country:

  1. Door may not latch because of insufficient grease

    Reported March 6, 2025Model years 2024NHTSA campaign 25V1470007,022 vehicles affected

    The door button mechanism may lack sufficient grease, preventing the door from fully latching. An unlatched door may open while driving, increasing the risk of injury. The door button assemblies will be replaced free of charge.

    Official NHTSA recall text
    Component
    STRUCTURE:BODY:DOOR:HANDLE:EXTERIOR
    Defect
    Ineos Automotive Americas, LLC (Ineos) is recalling certain 2024 Grenadier vehicles. The door button mechanism may have been assembled without a sufficient application of grease, preventing the door from fully latching.
    Consequence
    An unlatched door can open unexpectedly while the vehicle is in motion, increasing the risk of injury.
    Remedy
    Ineos will replace the door button assemblies, free of charge. Owner notification letters were mailed on September 12, 2025. Owners may contact Ineos customer service at 1-833-494-4748.
    Notes
    Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 888-327-4236 (TTY 888-275-9171) or go to nhtsa.gov.

  2. Steering joint nuts may not lock

    Reported March 11, 2024Model years 2023DVSA recall R/2024/044333 vehicles affected

    Incorrect non-locking nuts may have been used on steering rod ball joints. Each affected vehicle will be inspected, and any non-locking nuts found will be replaced with locking nuts.

    Official DVSA recall text
    Component
    Tie Rod and Drag Link Incorrect Non-Locking Nut
    Defect
    On certain MY23 and MY24 vehicles incorrect non-locking steering rod ball joint nuts may have been used during assembly instead of a locking nut.
    Remedy
    A physical inspection of each potentially affected vehicle will be performed. Any non-locking nuts found will be replaced with locking nuts as required.

  3. Steering rod nuts may come loose

    Reported December 29, 2023Model years 2024NHTSA campaign 23V90300061 vehicles affected

    Non-locking nuts may have been installed on the steering rod ball joint. Loose or missing nuts could disconnect the joint from the steering knuckle, causing loss of steering and increasing crash risk. Dealers will install locking nuts free of charge.

    Official NHTSA recall text
    Component
    STEERING:CRITICAL FASTENERS
    Defect
    Ineos Automotive Americas, LLC (Ineos) is recalling certain 2023-2024 Grenadier vehicles. Non-locking nuts may have been mistakenly installed on the steering rod ball joint.
    Consequence
    Loose or missing nuts can result in the steering rod ball joint disconnecting from the steering knuckle, causing a loss of steering and increasing the risk of a crash.
    Remedy
    Dealers will install locking steering rod ball joint nuts, free of charge. Owner notification letters were mailed June 25, 2024. Owners may contact Ineos customer service at 1-919-296-3626.
    Notes
    Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

  4. Relay control wire may short circuit

    Reported December 7, 2023Model years 2024NHTSA campaign 23V828000727 vehicles affected

    A trapped relay control wire may have damaged insulation and short circuit, increasing the risk of fire. Dealers will inspect and secure the wiring, and repair or replace damaged wiring as necessary, free of charge.

    Official NHTSA recall text
    Component
    ELECTRICAL SYSTEM:WIRING
    Defect
    Ineos Automotive Americas, LLC (Ineos) is recalling certain 2024 Grenadier vehicles equipped with the auxiliary switch package relay. The relay control wire may have been trapped under the relay power cable connection fastener during assembly, which can potentially damage the relay control wire insulation and result in a short.
    Consequence
    A short circuit increases the risk of fire.
    Remedy
    Dealers will inspect and secure the wiring, and repair or replace any damaged wiring as necessary, free of charge. Owner notification letters were mailed June 25, 2024. Owners may contact Ineos customer service at 1-919-296-3626.
    Notes
    Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Sources: NHTSA (US National Highway Traffic Safety Administration), DVSA (UK Driver and Vehicle Standards Agency) and the EU Safety Gate (European Commission) recall data. Each recall covers vehicles sold in that market; models sold elsewhere may differ.

Back to the INEOS Grenadier