Toyota Supra recalls
19 official safety recalls for the Toyota Supra from NHTSA (United States), DVSA (United Kingdom) and the EU Safety Gate, newest first. Recall repairs are normally free at the maker’s dealers.
Whether your car is affected and still needs the repair depends on its VIN or registration. Check it on the official site for your country:
- United States: nhtsa.gov/recalls
- United Kingdom: check-vehicle-recalls.service.gov.uk
Starter motor wear may cause failure or a fire
Unexpected wear inside the starter motor may stop the engine from starting and, in extreme cases, cause a thermal event or fire while starting or driving. The remedy is to replace the starter motor.
Official DVSA recall text
- Component
- RWT (reinforced water tightness) starter on Toyota 4-cylinder GR Supra
- Defect
- For affected vehicles due to unexpected wear on an internal component the starter motor may not function properly. In some cases this could lead to a non-starting engine or in extreme cases cause a thermal event or fire when attempting to start the engine or while driving.
- Remedy
- Replacement of the Starter motor.
Engine starter may overheat and catch fire
Wear on an internal component may cause the engine starter to overheat and catch fire, increasing injury risk. Dealers will replace the starter, free of charge.
Official NHTSA recall text
- Component
- ELECTRICAL SYSTEM:STARTER ASSEMBLY
- Defect
- BMW of North America, LLC (BMW) is recalling certain 2021-2023 Toyota Supra, 2022-2023 2 Series Coupe, 2021-2024 5 Series (xDrive), 2021-2022 Z4, 2022-2024 4 Series (Gran Coupe), 2021-2024 4 Series (Convertible and xDrive Convertible), 2021-2023 4 Series (Coupe), 2021-2024 3 Series, 2021-2023 X4, 2021-2024 X3 vehicles. Please see the recall report for a complete list of all models. The engine starter may overheat and catch fire due to wear on an internal component.
- Consequence
- Fire increases the risk of injury.
- Remedy
- Dealers will replace the engine starter, free of charge. Owner notification letters were mailed July 21, 2026. Owners may contact BMW customer service at 1-800-525-7417 or Toyota's customer service at 1-800-331-4331. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 24, 2026.
Starter relay may overheat and short circuit
Park outside: the maker advises parking affected vehicles outdoors, away from buildings, until they are repaired.
The engine starter relay may corrode, overheat and short circuit, increasing fire risk. Dealers will replace the engine starter free of charge. Park outside and away from structures until the repair is complete.
Official NHTSA recall text
- Component
- ELECTRICAL SYSTEM:STARTER ASSEMBLY:RELAY
- Defect
- BMW of North America, LLC (BMW) is recalling certain 2019-2021 BMW 330i, 2019-2022 BMW Z4, 2020-2022 BMW 530i, X3, X4, Toyota Supra, 2021-2022 BMW 430i, 430i Convertible, and 2022 BMW 230i vehicles. The engine starter relay may corrode, causing the relay to overheat and short circuit.
- Consequence
- A short circuit in the starter relay may increase the risk of a fire.
- Remedy
- Owners are advised to park their vehicles outside and away from structures until the remedy is complete. Dealers will replace the engine starter, free of charge. Owner notification letters were mailed February 6, 2026. Owners may contact BMW customer service at 1-800-525-7417. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov November 14, 2025.
Load capacity label may show incorrect weight values
The load carrying capacity modification label may show inaccurate added weight values, which could lead to overloading and increase crash risk. New labels will be mailed to owners free of charge.
Official NHTSA recall text
- Component
- EQUIPMENT:OTHER:LABELS
- Defect
- Gulf States Toyota, Inc. (GST) is recalling certain Toyota 2023 GR Supra, 2024 4 Runner, Corolla, Grand Highlander, Grand Highlander Hybrid, Land Cruiser Hybrid, Tacoma, Tacoma Hybrid, 2023-2024 BZ4X, Corolla Cross Hybrid, GR Corolla, GR86, Highlander, Highlander Hybrid, Prius, Prius Prime, Sequoia Hybrid, Tundra, Tundra Hybrid, Venza Hybrid, 2023-2025 Crown, and 2025 Camry Hybrid vehicles equipped with GST accessories. The load carrying capacity modification label may display inaccurate added weight values. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
- Consequence
- A vehicle with an incorrect maximum capacity weight value may be overloaded, which can increase the risk of a crash.
- Remedy
- GST will mail new labels to owners, free of charge. Owner notification letters were mailed September 16, 2024. Owners may contact GST customer service at 1-800-444-1074. GST's number for this recall is 24R2.
- Notes
- Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Transmission control computer case weld may be weak
The weld at the transmission control computer case joint may be insufficient. The transmission valve body will be replaced with one containing a new control computer.
Official DVSA recall text
- Component
- Affected vehicles are equipped with a transmission control computer where there is a possibility that the weld of the control computer case joint surface could be insufficient.
- Defect
- Affected vehicles are equipped with a transmission control computer where there is a possibility that the weld of the control computer case joint surface could be insufficient.�
- Remedy
- Replace the transmission valve body with a new one containing a new transmission control computer
Transmission oil may leak into control unit
A poorly manufactured weld on the transmission control unit cover may allow transmission oil to leak into the unit. This can seize the transmission gears and cause sudden loss of drive power. Dealers will replace the transmission mechatronics module and transmission fluid as necessary, free of charge.
Official NHTSA recall text
- Component
- POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
- Defect
- BMW of North America, LLC (BMW) is recalling certain 2023 Toyota GR Supra, 3 Series Sedan (330i xDrive, M340i xDrive, M3), 5 Series Sedan (530i, 530i xDrive, M5), 4 Series Gran Coupe (430i, 430i xDrive), 4 Series Coupe (430i, 430i xDrive, M440i xDrive), 4 Series Convertible (430i, 430i xDrive, M440i xDrive), 8 Series Coupe (840i, M850i xDrive, M8), 8 Series Convertible (840i, M850i xDrive, M8), 8 Series Gran Coupe (850i xDrive, M8), X3 SAV (X3 xDrive30i, X3M), X4 SAV (X4 xDrive30i), X5 SAV (X5 xDrive40i, X5 M50i, X5M), X6 SAV (X6 xDrive40i, X6 M50i, X6M), and Z4 sDrive30i, Z4 M40i vehicles. The weld seam of the integrated transmission control unit's cover may not have been manufactured properly, which could allow automatic transmission oil to leak into the transmission control unit.
- Consequence
- Transmission oil that leaks into the control unit can lead to a seizure of the transmission gears, causing a sudden loss of drive power and increasing the risk of a crash.
- Remedy
- Dealers will replace the transmission mechatronics module and the automatic transmission fluid, as necessary, free of charge. Owner notification letters were mailed January 26, 2024. Owners may contact BMW customer service at 1-800-525-7417.
- Notes
- Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Engine software may damage oil/vacuum pump
Engine management software could damage the oil/vacuum pump. The engine control unit software will be updated.
Official DVSA recall text
- Component
- ENGINE MANAGEMENT SOFTWARE COULD CAUSE THE OIL/VACUUM PUMP TO BECOME DAMAGED
- Defect
- Engine management software could cause the oil/vacuum pump to become damaged.
- Remedy
- Reflash the engine control unit (ECU).
Engine software may cause loss of braking assistance
During engine start, the engine management software may cause loss of braking assistance. Full mechanical braking remains available, but loss of assistance can increase crash risk. Dealers will update the engine management software free of charge.
Official NHTSA recall text
- Component
- ENGINE
- Defect
- BMW of North America, LLC (BMW) is recalling certain 2020 M340i, M340i xDrive, 540i, 540i xDrive, X3 M40i, 2020-2021 X4 M40i, 745Le xDrive, 2019-2021 Z4 M40i, and 2020-2021 Toyota Supra vehicles. During engine start, the engine management software may cause loss of braking assist. Full mechanical braking (without assist) remains available.
- Consequence
- Loss of braking assist can increase the risk of a crash.
- Remedy
- Dealers will update the engine management software, free of charge. Owner notification letters were mailed on September 17, 2021. Owners may contact BMW customer service at 1-800-525-7417.
- Notes
- Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Passenger seat belt retractor may deactivate early
The passenger seat belt's automatic locking retractor may deactivate before the webbing fully retracts. In a crash, a retractor that does not work as intended increases injury risk. Dealers will inspect the seat belt retractors and replace them if necessary, free of charge.
Official NHTSA recall text
- Component
- SEAT BELTS
- Defect
- BMW of North America, LLC (BMW) is recalling certain 2021 2 Series (230i, 230i xDrive, M240i, M240i xDrive), 330e, 330e Xdrive, 4 Series Coupe (430i, 430i xDrive, M440i xDrive) M4 Coupe, M4 Competition Coupe, BMW 4 Series Convertible (430i, M440i), BMW X1 sDrive28i, xDrive28i, 2 Series Gran Coupe (228i, 228i xDrive, M235i xDrive), M2 Competition Coupe, 330i, 330i xDrive, M340i, M340i xDrive, M3, M3 Competition, 530i, 530i xDrive, 540i, 540i xDrive, MINI Hardtop 2 Door (Cooper, CooperS, JCW), X2 sDrive28i, X2 xDrive28i, X2 M35i, Z4 sDrive30i, Z4 M40i, MINI Hardtop 2 Door (Cooper SE), MINI Convertible (Cooper, Cooper S, JCW), MINI Clubman (Cooper S, Cooper S All4, JCW), MINI Countryman (Cooper, Cooper All4, Cooper S, Cooper S All4, JCW All4), Rolls Royce Ghost, MINI Countryman (Cooper S E All4), Rolls Royce Phantom, Rolls Royce Cullinan, and Toyota Supra vehicles. The passenger seat belt Automatic Locking Retractor (ALR) may deactivate early, before the webbing fully retracts. As such, these assemblies fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
- Consequence
- During a crash, a seat belt retractor that does not function as intended increases the risk of injury.
- Remedy
- Dealers will inspect the seat belt retractors (including the seat belts) and, if necessary, replace the retractors, free of charge. Owner notification letters were mailed on September 3, 2021. Owners may contact BMW customer service at 1-800-525-7417; 1-866-825-1525 (MINI); 1-877-877-3735 (Rolls Royce); and 1-888-270-9371 (Toyota).
- Notes
- Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Fuel tank may leak
The fuel tank may have been improperly welded and could leak fuel. The fuel tank will be replaced.
Official DVSA recall text
- Component
- THE FUEL TANK MAY NOT HAVE BEEN WELDED PROPERLY AND COULD LEAK FUEL
- Defect
- The fuel tank in the subject vehicles may not have been welded properly and could leak fuel.
- Remedy
- Replace the Fuel Tank.
Fuel tank weld may fail and leak
An insufficient weld between the fuel tank halves may fail and allow fuel to leak, increasing fire risk if there is an ignition source. Dealers will replace the fuel tank free of charge.
Official NHTSA recall text
- Component
- FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
- Defect
- BMW of North America, LLC (BMW) is recalling certain 2020-2021 Z4 and 2020-2021 Toyota Supra vehicles. The weld between the fuel tank halves may have been insufficiently welded, causing the weld to fail.
- Consequence
- The failed weld may allow fuel to leak, increasing the risk of a fire in the presence of an ignition source.
- Remedy
- BMW will notify owners, and dealers will replace the fuel tank, free of charge. The recall began December 18, 2020. Owners may contact BMW customer service at 1-800-525-7417 or Toyota customer service at 1-888-270-9371.
- Notes
- Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Headlamps may be adjusted horizontally
The headlamps can be adjusted horizontally, which could cause glare and reduce visibility for oncoming drivers or the vehicle operator, increasing crash risk. Dealers will inspect and correct the adjustment plugs as needed, free of charge.
Official NHTSA recall text
- Component
- EXTERIOR LIGHTING:HEADLIGHTS
- Defect
- BMW of North America, LLC (BMW) is recalling certain 2019-2020 Z4 sDrive30i, Z4 M40i and 2020 Toyota Supra vehicles. The headlamps are able to be adjusted horizontally. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices and Associated Equipment."
- Consequence
- Should the headlamps be adjusted horizontally, there could be increased glare and reduced visibility for oncoming drivers, or reduced visibility for the vehicle operator, thereby increasing the risk of a crash.
- Remedy
- BMW will notify owners, and dealers will inspect the headlamp vertical and horizontal adjustment plugs, correcting them as necessary, free of charge. The recall began December 23, 2020. BMW owners may contact BMW customer service at 1-800-525-7417 or Toyota owners may contact Toyota customer service at 1-888-270-9371.
- Notes
- Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Steering tie rod may fracture
High temperatures and rough roads may damage a steering gear tie rod, which could fracture and affect handling and control, increasing crash risk. Dealers will replace the steering gear tie rods free of charge.
Official NHTSA recall text
- Component
- STEERING:LINKAGES:TIE ROD ASSEMBLY
- Defect
- BMW of North America, LLC (BMW) is recalling certain 2019 Z4 sDrive30i, 2019-2020 330i xDrive, M340i and M340i xDrive, 2020 X3M and X4M, and Toyota Supra vehicles. In certain driving conditions, such as high temperatures and rough road surfaces, a steering gear tie rod may become damaged, possibly resulting in a fractured tie rod.
- Consequence
- A damaged or fractured tie rod may affect vehicle handling and control, increasing the risk of a crash.
- Remedy
- BMW and Toyota will notify owners, and dealers will replace the steering gear tie rods, free of charge. The recall began August 14, 2020. Owners may contact BMW customer service at 1-800-525-7417 or Toyota customer service at 1-888-270-9371.
- Notes
- Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Driver air bag inflator may rupture or underinflate
Moisture may cause the driver air bag inflator to rupture or the air bag to underinflate, potentially sending metal fragments toward occupants or reducing protection in a crash. Owners may self-inspect or have a dealer inspect the steering wheel; dealers will inspect potentially affected inflators and replace them as needed, free of charge.
Official NHTSA recall text
- Component
- AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
- Defect
- Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 1998-2000 RAV4, 1998-1999 RAV4 EV and Celica and 1997-1998 Supra vehicles. These vehicles were equipped with Non-Azide Driver air bag Inflators (NADI) and do not contain phase stabilized ammonium nitrate (PSAN) propellant. Due to a manufacturing issue, the NADI inflators may absorb moisture, causing the inflators to rupture or the air bag cushion to underinflate.
- Consequence
- In the event of a crash necessitating air bag deployment, an inflator rupture may result in metal fragments striking the driver or other occupants. An underinflated air bag may not properly protect the occupant, and increases the risk of serious injury or death.
- Remedy
- Toyota will notify owners, and owners will have the option to self-inspect, or have a dealer inspect the steering wheel on their vehicle to determine if their vehicle may be equipped with an affected inflator. Potentially affected steering wheel serial numbers will be inspected by a dealer. Based on the inspection, dealers will replace the front driver air bag inflator with an alternate one, as necessary. These repairs will be performed free of charge. The recall began August 28, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's numbers for this recall is 20TB01 and 20TA01.
- Notes
- Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Headlight control unit may fail
A headlight control unit may fail, causing one or both headlights to stop working and reducing driver visibility, which can increase crash risk. Dealers will replace the control units free of charge.
Official NHTSA recall text
- Component
- EXTERIOR LIGHTING:HEADLIGHTS
- Defect
- BMW of North America, LLC (BMW) is recalling certain 2020 Z4 M40i, Z4 sDrive30i, 330i and 330i xDrive vehicles as well as 2020 Toyota Supra vehicles. The headlight control units may fail causing a loss of one or both of the headlights.
- Consequence
- Headlight failure can reduce the driver's visibility, increasing the risk of a crash.
- Remedy
- BMW will notify owners, and dealers will replace the headlight control units, free of charge. The recall is expected to begin January 17, 2020. Owners may contact BMW customer service at 1-800-525-7417 or Toyota customer service at 1-888-270-9371.
- Notes
- Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Backup camera image may not display in reverse
The backup camera settings may leave the rear view image blank, including the next time the vehicle is placed in reverse, increasing crash risk. Dealers will update the camera software free of charge.
Official NHTSA recall text
- Component
- BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
- Defect
- BMW of North America, LLC (BMW) is recalling certain 2018 540d, 2018-2020 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 530e, 530e xDrive, X3 sDrive, X3 xDrive, X3 M40i, X3 M, and 2019-2020 X4 xDrive, X4 M40i, X4 M, X7 xDrive, X7 M50i, 740Li, 740Li xDrive, 750Li, 750Li xDrive, 8 Series Convertible and Coupe 840i, 840i xDrive, M850i xDrive, X5 sDrive, X5 xDrive, X5 M50i, X6 xDrive, X6 M50i, 330i, 330i xDrive, M340i, M340i xDrive, Z4 sDrive, Z4 M40i, 740Le xDrive and 745Le xDrive, 2018-2019 640i xDrive Gran Turismo and Rolls-Royce Phantom, 2019 M850i xDrive Gran Coupe and Rolls-Royce Cullinan and 2020 Toyota Supra vehicles. The back-up camera and display settings can be adjusted such that the rear view image is no longer visible and the system will retain that setting the next time the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."
- Consequence
- The lack of an image in the back-up camera display increases the risk of a crash.
- Remedy
- BMW will notify owners, and dealers will update the back-up camera software, free of charge. The recall began November 8, 2019. Owners may contact BMW customer service at 1-800-525-7417 or Rolls-Royce at 1-877-877-3735. Toyota owners may contact Toyota customer service at 1-888-270-9371.
- Notes
- Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Driver's seat belt guide mount may be improperly welded
The driver's seat belt guide loop mount may be improperly welded and could become damaged in a crash, leaving the belt unable to properly restrain the driver and increasing injury risk. Toyota dealers will inspect the mount and replace the vehicle if it is defective, free of charge.
Official NHTSA recall text
- Component
- SEAT BELTS:FRONT
- Defect
- BMW of North America, LLC (BMW) is recalling certain 2020 Toyota Supra vehicles. The driver's seat belt guide loop mount may have been improperly welded.
- Consequence
- In the event of a crash, the mount could become damaged and the seat belt may not properly restrain the driver, increasing their risk of injury.
- Remedy
- Owners have been notified, and Toyota dealers will inspect the seat belt guide loop mount. If the mount is defective, the vehicle will be replaced, free of charge. The recall began October 16, 2019. Owners may contact the Toyota Customer Experience Center at 1-888-270-9371. Toyota's number for this recall is K0R.
- Notes
- Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Oil pressure sender may leak or cause engine lock-up
Under high temperature and pressure, a defective oil pressure sender may leak oil or cause the engine to lock up. The sender will be replaced at no cost to the owner.
Official NHTSA recall text
- Component
- ENGINE AND ENGINE COOLING:ENGINE
- Defect
- OIL PRESSURE SENDER GAUGE MAY BE DEFECTIVE. CONTINUED ENGINE OPERATION UNDER HIGH TEMPERATURE AND HIGH PRESSURE MAY CAUSE THE SENDING UNIT TO LEAK OIL OR MAY CAUSE THE ENGINE TO LOCK UP.
- Remedy
- REPLACEMENT OF THE OIL SENDER GAUGE WITHOUT COST TO THE OWNER.
- Notes
- VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 5M-GE ENGINES AND ANALOGINSTRUMENT PANELS WITH OIL PRESSURE GAUGE (NOT A WARNING LIGHT).SYSTEM: ENGINE; OIL PRESSURE SENDER GAUGE.CONSEQUENCES OF DEFECT: EITHER CONDITION COULD OCCUR WITHOUT PRIOR WARNING, ANDLOSS OF VEHICLE CONTROL AND AN ACCIDENT COULD RESULT.
Voltage regulator may overcharge battery
A manufacturing error in the voltage regulator's integrated circuit may cause it to overcharge the battery. The dealer will replace the regulator at no charge.
Official NHTSA recall text
- Component
- ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR
- Defect
- VOLTAGE REGULATOR WHICH CONTROLS THE AMOUNT OF FLOW IN THE ELECTRICAL SYSTEM BETWEEN THE BATTERY AND THE ALTERNATOR, MAY HAVE MANUFACTURING ERRORS IN AN INTEGRATED CIRCUIT. THE REGULATOR MAY OVERCHARGE THE BATTERY.
- Remedy
- DEALER WILL REPLACE THE VOLTAGE REGULATOR AT NO CHARGE.
- Notes
- VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: ELECTRICAL; VOLTAGE REGULATOR.CONSEQUENCES OF DEFECT: OVERCHARGING CAN DAMAGE THE BATTERY AND MAY RESULT INLOSS OF ELECTRICAL POWER WITHOUT WARNING. LOSS OF LIGHTS AND ENGINE IGNITIONCOULD RESULT IN LOSS OF VEHICLE CONTROL AND A POSSIBLE ACCIDENT.
Sources: NHTSA (US National Highway Traffic Safety Administration), DVSA (UK Driver and Vehicle Standards Agency) and the EU Safety Gate (European Commission) recall data. Each recall covers vehicles sold in that market; models sold elsewhere may differ.