Kia Sorento recalls

68 official safety recalls for the Kia Sorento from NHTSA (United States), DVSA (United Kingdom) and the EU Safety Gate, newest first. Recall repairs are normally free at the maker’s dealers.

Whether your car is affected and still needs the repair depends on its VIN or registration. Check it on the official site for your country:

United States: nhtsa.gov/recalls
United Kingdom: check-vehicle-recalls.service.gov.uk

Instrument cluster may reset or display a green image
Reported April 24, 2026Model years 2025DVSA recall R/2026/1398,730 vehicles affected
The instrument cluster may respond slowly after starting. Using the turn signal during this condition may reset the cluster or turn the Blind View Monitor image green. An over-the-air or dealer software update will be applied.
Official DVSA recall text
Component
Kia Cluster Malfunction Recall
Defect
The instrument cluster screen may respond slowly immediately after starting the vehicle. During this condition activating the turn signal can cause the cluster to reset or the Blind View Monitor (BVM) within the cluster to turn green. The malfunction is caused by PMIC noise induced falsely high temperature sensor readings which trigger the chip protection logic above a certain threshold and lead to performance limitation up to reboot or black screen.
Remedy
Over The Air software update or dealer software update
Instrument panel display may fail
Reported January 26, 2026Model years 2025–2026NHTSA campaign 26V04600042,677 vehicles affected
A software error may cause the instrument panel display to fail, hiding safety information such as speed, tyre pressure or warning lights and increasing crash risk. The display software will be updated over the air or by a dealer, free of charge.
Official NHTSA recall text
Component
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
Defect
Kia America, Inc. (Kia) is recalling certain 2025 Kia K4, 2025-2026 Sorento, Sorento Hybrid, Sorento Plug-In Hybrid Electric (PHEV), 2026 Sportage, Sportage Hybrid, Sportage PHEV, K5, EV9, Carnival, and Carnival Hybrid vehicles. Due to a software error, the instrument panel display may fail. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 101, "Controls and Displays" and 138, "Tire Pressure Monitoring System."
Consequence
An instrument panel display that fails to show critical safety information, such as the speedometer, tire pressure, or warning lights, increases the risk of a crash.
Remedy
The instrument panel display software will be updated over-the-air (OTA) or by a dealer, free of charge. Owner notification letters are expected to be mailed March 26, 2026. Owners may contact Kia Customer Service at 1-800-333-4542. Kia's number for this recall is SC361. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on February 9, 2026.
Incorrect spare tire may affect braking systems
Reported October 30, 2025Model years 2026NHTSA campaign 25V74500045 vehicles affected
The incorrect spare tire can impair the anti-lock braking and traction control systems when installed, increasing crash risk. Dealers will replace the spare wheel and tire assembly free of charge.
Official NHTSA recall text
Component
TIRES:TEMPORARY/EMERGENCY SPARE TIRE
Defect
Kia Motors America (Kia) is recalling certain 2025 Telluride and 2026 Sorento vehicles. The vehicles are equipped with an incorrect spare tire which, when installed, can impair the anti-lock braking system (ABS) and the traction control system (TCS). As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Consequence
Anti-lock braking or traction control systems that do not function properly can increase the risk of a crash.
Remedy
Dealers will replace the spare wheel and tire assembly, free of charge. Owner notification letters were mailed December 3, 2025. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC355. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning November 13, 2025.
HVAC blower wiring harness may cause a fire
Reported September 25, 2025Model years 2021–2023NHTSA campaign 25V64900039,536 vehicles affected
The HVAC blower motor wiring harness may be inadequate and could cause a fire, increasing the risk of injury. Dealers will replace the wiring harness and blower motor resistor free of charge.
Official NHTSA recall text
Component
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR
Defect
Kia America, Inc. (Kia) is recalling certain 2021-2023 Sorento vehicles. The heating, ventilation, and air conditioning (HVAC) blower motor wiring harness may be inadequate, which can result in a fire.
Consequence
A fire increases the risk of injury.
Remedy
Dealers will replace the wiring harness and blower motor resistor, free of charge. Owner notification letters were mailed January 23, 2026. Owners may contact Kia customer service at 800-333-4542. Kia's number for this recall is SC351. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning October 9, 2025.
Connecting rod bolts may cause engine failure
Reported August 25, 2025Model years 2025NHTSA campaign 25V54800030 vehicles affected
Improperly tightened connecting rod bolts may cause loss of drive power, increasing crash risk. Dealers will replace the sub-engine assembly, free of charge.
Official NHTSA recall text
Component
ENGINE AND ENGINE COOLING:CRITICAL FASTENERS
Defect
Kia America, Inc. (Kia) is recalling certain 2025 K4 and Sorento vehicles. The connecting rod bolts in the engine may have been improperly tightened, which can cause a loss of drive power.
Consequence
A loss of drive power increases the risk of a crash.
Remedy
Dealers will replace the sub engine assembly, free of charge. Owner notification letters are expected to be mailed September 12, 2025. Owners may contact Kia customer service at 800-333-4542. Kia's number for this recall is SC349.
Daytime running light may stay off
Reported April 3, 2025Model years 2023–2024DVSA recall R/2025/1301,366 vehicles affected
After the turn signal or hazard lights have operated for more than 5 minutes, the upper part of the daytime running light may stay off when the signal is switched off, reducing its intensity below the required standard. A software update will be provided over the air; if that fails or is declined, a dealer will update the software.
Official DVSA recall text
Component
Kia Sorento MQ4 PDC Recall
Defect
When the turn signal is switched off after operating the turn signal or hazard light more than 5 minutes the upper part of Daytime Running Light (DRL) stays off. The DRL will subsequently not meet the required intensity standard.
Remedy
Kia will issue a software update via OTA (Over the Air) if this fails or a customer refuses the OTA update a Kia dealer will update the software.
Software error may disable low beams and taillights
Reported January 13, 2025Model years 2024–2025NHTSA campaign 25V00600074,469 vehicles affected
A software error in the body control unit may cause the low beam headlights and taillights to stop working, reducing visibility and increasing the risk of a crash. Dealers will update the software, free of charge.
Official NHTSA recall text
Component
ELECTRICAL SYSTEM:BODY CONTROL MODULE:SOFTWARE
Defect
Kia America, Inc. (Kia) is recalling certain 2024-2025 Sorento, 2025 Sorento Hybrid, and 2025 Sorento Plug-In Hybrid vehicles. A software error in the Body Domain Control Unit (BDC) may cause a loss of low beam headlights and taillights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence
A loss of headlights and taillights can reduce visibility, increasing the risk of a crash.
Remedy
Dealers will update the BDC software, free of charge. Owner notification letters were mailed February 21, 2025. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC331.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153) or go to nhtsa.gov.
Steering rack may damage fuel line in a crash
Reported December 10, 2024Model years 2025NHTSA campaign 24V9200001,385 vehicles affected
In a crash, the steering rack may damage the fuel line, causing a leak that can increase the risk of fire if there is an ignition source. Dealers will install a cover around the fuel line free of charge.
Official NHTSA recall text
Component
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Defect
Kia America, Inc. (Kia) is recalling certain 2025 Sorento Plug-In Hybrid vehicles. During a crash, the steering rack may damage the fuel line, which can result in a fuel leak.
Consequence
A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy
Dealers will install a cover around the fuel line, free of charge. Owner notification letters were mailed January 10, 2025. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC328.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153) or go to nhtsa.gov.
Brake control unit may overheat
Reported December 5, 2024Model years 2010–2014DVSA recall R/2024/465160,314 vehicles affected
The hydraulic electronic control unit may leak internally and cause an electrical short. In extreme cases it may overheat, creating a risk of an under-bonnet fire. The junction box fuses will be replaced with lower-rated fuses.
Official DVSA recall text
Component
Kia HECU Fuse Replacement
Defect
The HECU hydraulic electronic control unit of affected vehicles equipped with Anti-lock Brake Systems ABS and Electronic Stability Control ESC could leak internally and cause an electrical short over time. In extreme cases the HECU could overheat with a possible risk of an under bonnet fire.
Remedy
The recall will replace the fuses in the junction box with a lower rated version.
Power steering wiring harness may cause loss of assist
Reported April 23, 2024Model years 2024NHTSA campaign 24V28700095 vehicles affected
An incorrectly assembled power steering wiring harness may cause loss of power steering assist, increasing crash risk. Dealers will inspect and repair or replace the harness as necessary, free of charge.
Official NHTSA recall text
Component
ELECTRICAL SYSTEM:WIRING
Defect
Kia America, Inc. (Kia) is recalling certain 2024 Sorento vehicles. The motor driven power steering (MDPS) wiring harness may be incorrectly assembled, which can result in a loss of power steering assist.
Consequence
A loss of power steering assist increases the risk of a crash.
Remedy
Dealers will inspect and repair, or replace the MDPS wiring harness as necessary, free of charge. Owner notification letters were mailed May 7, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC309.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Engine compartment fire may occur while driving
Reported December 21, 2023Model years 2011NHTSA campaign 23V87700079,812 vehicles affected
An engine compartment fire can occur while driving, increasing the risk of injury. Dealers will install Knock Sensor Detection System software and replace the engine as necessary, free of charge.
Official NHTSA recall text
Component
ENGINE
Defect
Kia America, Inc. (Kia) is recalling certain 2011 Sorento vehicles. An engine compartment fire can occur while driving.
Consequence
A fire increases the risk of injury.
Remedy
Dealers will install Knock Sensor Detection System (KSDS) software and replace the engine as necessary, free of charge. Owner notification letters were mailed February 9, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC291.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
HECU may short circuit and cause fire
Reported September 25, 2023Model years 2011–2014NHTSA campaign 23V6520001,730,192 vehicles affected
Park outside: the maker advises parking affected vehicles outdoors, away from buildings, until they are repaired.
The Hydraulic Electronic Control Unit may experience an electrical short, potentially starting an engine compartment fire while parked or driving. Park outside and away from structures until repaired. Dealers will replace the HECU fuse free of charge.
Official NHTSA recall text
Component
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE
Defect
Kia America, Inc. (Kia) is recalling certain 2010-2019 Borrego, 2014-2016 Cadenza, 2010-2013 Forte, Forte Koup, Sportage, 2015-2018 K900, 2011-2015 Optima, 2011-2013 Optima Hybrid, Soul, 2012-2017 Rio, 2011-2014 Sorento, and 2010-2011 Rondo vehicles. The Hydraulic Electronic Control Unit (HECU) may experience an electrical short, which can result in an engine compartment fire while parked or driving.
Consequence
An engine compartment fire while parked or driving can increase the risk of injury.
Remedy
Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the HECU fuse, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed November 14, 2023. Owner notification letters were mailed March 29, 2024 through June 18, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC284.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Turn signals may not activate intermittently
Reported September 18, 2023Model years 2022DVSA recall R/2023/2691,013 vehicles affected
Poor contact in the multifunction switch may prevent the turn signals from activating intermittently. A software update will increase the control system’s acceptable range.
Official DVSA recall text
Component
Turn signals may not activate intermittently due to improper switch contact in the multifunction switch
Defect
Turn signals may not activate intermittently due to improper switch contact in the multifunction switch
Remedy
Software update for the multifunction switch which increases the acceptable range for the control system
Water may enter rearview camera and disable image
Reported September 15, 2023Model years 2019NHTSA campaign 23V63900083,667 vehicles affected
Water may leak into the rearview camera and prevent its image from displaying, reducing the driver's view behind the vehicle. Dealers will inspect the camera, add waterproofing to the harness or replace the camera as needed, free of charge.
Official NHTSA recall text
Component
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Defect
Kia America, Inc. (Kia) is recalling certain 2019 Sorento vehicles. Due to a manufacturing error, water may leak into the rearview camera, which can cause the rearview camera image not to appear on the display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence
A rearview camera that does not display an image can reduce the driver's rear view, increasing the risk of a crash.
Remedy
Dealers will inspect the rearview camera and add additional water proofing to the camera harness, or replace the camera as necessary, free of charge. Owner notification letters were mailed March 8, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC282.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Rearview camera mounting clips may break
Reported August 31, 2023Model years 2022–2023NHTSA campaign 23V610000144,979 vehicles affected
The rearview camera mounting clips may break, preventing the image from displaying properly and reducing the driver's view behind the vehicle. Dealers will inspect and replace the camera housing as needed, free of charge.
Official NHTSA recall text
Component
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Defect
Kia America, Inc. (Kia) is recalling certain 2022-2023 Sorento, Sorento Hybrid, and Sorento Plug-in Hybrid (PHEV) vehicles. The mounting clips for the rearview camera may break, which can cause the rearview camera image not to appear properly on the display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence
A rearview camera that does not properly display an image can reduce the driver's rear view, increasing the risk of a crash.
Remedy
Dealers will inspect and replace the rearview camera housing, as necessary, free of charge. Owner notification letters were mailed October 27, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC280.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Air bag warning labels may detach
Reported August 15, 2023Model years 2023NHTSA campaign 23V57900050,517 vehicles affected
The air bag warning labels on the front sun visors may detach, leaving occupants without warnings about deployment risks and increasing injury risk in a crash. Dealers will inspect and replace the visors as needed, free of charge.
Official NHTSA recall text
Component
EQUIPMENT:OTHER:LABELS
Defect
Kia America, Inc. (Kia) is recalling certain 2023 Sorento vehicles. The air bag warning labels on the driver and front passenger sun visors may detach. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence
A detached air bag warning label will not warn occupants about the risks of air bag deployment, increasing the risk of injury in a crash.
Remedy
Dealers will inspect and replace the driver and front passenger sun visors, as necessary, free of charge. Owner notification letters were mailed October 10, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC277.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Fuel tank may leak
Reported April 24, 2023Model years 2022DVSA recall R/2023/07714 vehicles affected
Poor moulding of the plastic fuel tank may cause a fuel leak. The fuel tank will be replaced.
Official DVSA recall text
Component
Poor moulding of the plastic fuel tank by a temporary supplier can lead to a potential fuel leak
Defect
Poor moulding of the plastic fuel tank by a temporary supplier can lead to a potential fuel leak
Remedy
Replace the fuel tank.
PTC heater may overheat and pose a fire risk
Reported February 6, 2023Model years 2012–2014DVSA recall R/2022/3436,377 vehicles affected
Damage to the connector terminal may cause the PTC heater to overheat and malfunction, creating a fire risk. The relay will be replaced and the wiring fixing point moved. If there is local thermal damage, the PTC core and connector will also be replaced.
Official DVSA recall text
Component
The PTC (positive temperature coefficient) heater in some Sorento (XM) models can overheat due to potential damage of the connector terminal. This can lead to a malfunction of the PTC heater and a risk of fire.
Defect
The PTC (positive temperature coefficient) heater in some Sorento (XM) diesel models can overheat due to potential damage of the connector terminal. This can lead to a malfunction of the PTC heater and a risk of fire.
Remedy
Replace the PTC relay and move the wiring fixing point. In cases of local thermal damage of PTC replace the PTC core and connector.
Fuel tank may leak
Reported January 25, 2023Model years 2022NHTSA campaign 23V02700034 vehicles affected
An improperly molded fuel tank may leak fuel, which can increase the risk of fire if fuel meets an ignition source. Dealers will inspect and replace the tank as necessary, free of charge.
Official NHTSA recall text
Component
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
Defect
Kia America, Inc. (Kia) is recalling certain 2022 Sorento Plug-In Hybrid (PHEV) vehicles. The fuel tank may have been improperly molded, which can result in a fuel leak.
Consequence
A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy
Deales will inspect and replace the fuel tank, as necessary, free of charge. Owner notification letters were mailed March 22, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC261.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Transmission oil pump may develop an internal fault
Reported January 9, 2023Model years 2020–2022DVSA recall R/2022/363916 vehicles affected
The high-pressure electric oil pump in the eight-speed dual-clutch transmission may develop an internal fault. The transmission control unit software will be upgraded; in rare cases, the transmission may also need replacement.
Official DVSA recall text
Component
The High Pressure Electric Oil Pump within the eight-speed dual-clutch transmission (DCT) may experience an internal fault
Defect
The High-Pressure Electric Oil Pump within the eight-speed dual-clutch transmission (DCT) may experience an internal fault.
Remedy
Upgrade the software of the Transmission Control Unit (TCU). In rare cases it may be necessary to also replace the transmission.
Gear shift lever may move out of Park without the brake
Reported November 30, 2022Model years 2015DVSA recall R/2022/328295 vehicles affected
The gear shift lever may move out of Park without the foot brake applied. If the parking brake is not on, the vehicle could roll away. The gear shift lock will be checked and the lever assembly replaced if it does not work correctly.
Official DVSA recall text
Component
There is a risk the automatic gear shift lever could be moved out of Park without the foot brake pedal being applied. If this occurs and should the parking brake not be activated a vehicle rollaway could occur.
Defect
There is a risk the automatic gear shift lever could be moved out of Park without the foot brake pedal being applied. If this occurs and should the parking brake not be activated a vehicle rollaway could occur.
Remedy
Check operation of the gear shift lock mechanism and if found to be incorrect replace the Gear shift lock lever assembly.
Transmission fault may cause loss of drive power
Reported October 11, 2022Model years 2021–2022NHTSA campaign 22V76000069,038 vehicles affected
A transmission oil pump malfunction may impair the limited-mobility drive mode and cause a complete loss of drive power, increasing crash risk. Dealers will inspect and replace the transmission as needed, and update its control unit software, free of charge.
Official NHTSA recall text
Component
POWER TRAIN:AUTOMATIC TRANSMISSION
Defect
Kia Motors, Inc. (Kia) is recalling certain 2021-2022 Sorento and 2021-2023 K5 vehicles. The vehicle's "fail-safe" limited-mobility drive mode may be impaired, when prompted by a transmission oil pump malfunction, which can result in a complete loss of drive power.
Consequence
Loss of drive power increases the risk of a crash.
Remedy
Dealers will inspect and replace the transmission, as necessary. Dealers will also update the transmission control unit software. All repairs will be performed free of charge. Owner notification letters were mailed December 9, 2022. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC250.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Tow hitch wiring may short circuit
Reported September 19, 2022Model years 2016–2023NHTSA campaign 22V70300070,887 vehicles affected
Park outside: the maker advises parking affected vehicles outdoors, away from buildings, until they are repaired.
Debris and moisture on the tow hitch harness circuit board may cause a short circuit and fire. Park outside and away from structures until repaired. Dealers will inspect and replace the fuse and/or harness module as needed, free of charge.
Official NHTSA recall text
Component
TRAILER HITCHES
Defect
Kia America, Inc. (Kia) is recalling certain 2016-2022 Sorento, 2021-2022 Sorento Hybrid (HEV), 2022-2023 Sorento Plug-In Hybrid (PHEV), and 2017-2022 Sportage vehicles equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Debris and moisture accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
Consequence
A fire while parked or driving can increase the risk of injury.
Remedy
Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will inspect the vehicle, and, as necessary, replace the fuse and/or tow hitch harness module, free of charge. Owner notification letters were mailed August 11, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC249.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Shift lever may not lock
Reported August 10, 2022Model years 2016NHTSA campaign 22V61200028,065 vehicles affected
Faulty shift lever assembly components may prevent the lever from locking, allowing the vehicle to roll away and increasing crash and injury risk. Dealers will inspect and replace components as needed, free of charge.
Official NHTSA recall text
Component
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
Defect
Kia America, Inc. (Kia) is recalling certain 2016 Sedona and Sorento vehicles. The vehicles may have been manufactured with faulty automatic transmission shift lever assembly components, preventing the shift lever from locking, which can allow the vehicle to rollaway.
Consequence
A vehicle rollaway increases the risk of a crash and injury.
Remedy
Dealers will inspect and replace the automatic transmission shift lever assembly components, as necessary, free of charge. Owner notification letters were mailed October 7, 2022. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC246.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Incorrect spare tyre may impair ABS and traction control
Reported July 19, 2022Model years 2022NHTSA campaign 22V5090008 vehicles affected
An incorrect spare tyre may impair the anti-lock braking and traction control systems when installed, increasing crash risk. Dealers will inspect and replace the spare tyre as needed, free of charge.
Official NHTSA recall text
Component
TIRES:TEMPORARY/EMERGENCY SPARE TIRE
Defect
Kia Motors America (Kia) is recalling certain 2022 Sorento and Telluride vehicles. The vehicles may be equipped with an incorrect spare tire which, when installed, can impair the anti-lock braking system (ABS) and the traction control system (TCS). As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Consequence
Impaired anti-lock braking or traction control systems can increase the risk of a crash.
Remedy
Dealers will inspect and replace the spare tire, as necessary, free of charge. Owner notification letters were mailed July 27, 2022. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC244.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Seat belt pretensioner may explode when deployed
Reported June 23, 2022Model years 2021–2022NHTSA campaign 22V44700017,199 vehicles affected
A front seat belt pretensioner may explode during a crash, projecting metal fragments into the vehicle and injuring occupants. Dealers will secure the pretensioners with a cap free of charge.
Official NHTSA recall text
Component
SEAT BELTS:PRETENSIONER
Defect
Kia Motors America (Kia) is recalling certain 2021-2022 Sorento Hybrid and 2022 Sorento Plug-in Hybrid vehicles. In the event of a crash, the front driver-side and/or passenger-side seat belt pretensioner(s) may explode upon deployment.
Consequence
An exploding seat belt pretensioner can project metal fragments into the vehicle, striking vehicle occupants and resulting in injury.
Remedy
Dealers will secure the seat belt pretensioners with a cap, free of charge. Owner notification letters were mailed August 17, 2022. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC241. This recall expands and replaces NHTSA recall number 22V-127. Vehicles already repaired under the previous recall will need to have the new remedy completed.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Diesel fuel line may leak
Reported May 24, 2022Model years 2020DVSA recall R/2022/143326 vehicles affected
The low pressure diesel fuel line mounted to the engine may develop a leak. It will be replaced with an improved part.
Official DVSA recall text
Component
A FUEL LEAK CAN DEVELOP ON THE DIESEL LOW PRESSURE FUEL LINE
Defect
It has been found that a fuel leak can develop on the diesel low pressure fuel line which is mounted to the engine.
Remedy
Replace the low pressure fuel line module with improved parts.
Front left seat belt pretensioner may be faulty
Reported May 20, 2022Model years 2021DVSA recall R/2022/14749 vehicles affected
A manufacturing fault has been identified in the front left seat belt pretensioner. It will be replaced.
Official DVSA recall text
Component
A FAULT HAS BEEN IDENTIFIED IN THE MANUFACTURE OF THE FRONT L/H SEAT BELT PRE-TENSIONER
Defect
A fault has been identified in the manufacture of the front L/H seatbelt pre-tensioner.
Remedy
Replace the front L/H seatbelt pre-tensioner.
PTC heater connector may overheat
Reported May 3, 2022Model years 2014–2020DVSA recall R/2022/10415,665 vehicles affected
A damaged connector terminal may cause the PTC heater to overheat. The connector will be inspected; if damaged, the heater and relevant wiring connector will be replaced, and the heater operating logic upgraded.
Official DVSA recall text
Component
THE ELECTRICAL CONNECTOR TO THE PTC HEATER CAN OVERHEAT
Defect
The PTC (positive temperature coefficient) heater in some Sorento diesel models can overheat due to damaged connector terminal.
Remedy
Inspect and if the PTC connector is found damaged replace the PTC and relevant wiring connector. Upgrade the operating logic of the PTC
Turbocharger oil supply pipe may crack and leak
Reported March 29, 2022Model years 2022NHTSA campaign 22V20200026 vehicles affected
The turbocharger oil supply pipe may crack and leak oil in the engine compartment. If oil contacts hot engine or exhaust components, it can increase the risk of fire. Dealers will replace the pipe free of charge.
Official NHTSA recall text
Component
ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:PIPES, HOSES, AND FITTINGS
Defect
Kia Motor America (Kia) is recalling certain 2022 Sorento vehicles. The oil supply pipe to the turbocharger may crack, which could result in an oil leak in the engine compartment.
Consequence
An oil leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Remedy
Dealers will replace the turbocharger oil supply pipe, free of charge. Owner notification letters were mailed April 22, 2022. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC233.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Front seat belt pretensioners may explode
Reported March 4, 2022Model years 2022NHTSA campaign 22V127000213 vehicles affected
The front seat belt pretensioners may explode when deployed in a crash, sending metal fragments into the vehicle and injuring occupants. Dealers will replace the pretensioners, free of charge.
Official NHTSA recall text
Component
SEAT BELTS:FRONT
Defect
Kia Motors America (Kia) is recalling certain 2022 Sorento Hybrid and Sorento Plug-in Hybrid vehicles. In the event of a crash, the front driver-side and/or passenger-side seat belt pretensioner(s) may explode upon deployment.
Consequence
An exploding seat belt pretensioner can project metal fragments into the vehicle, striking vehicle occupants and resulting in injury.
Remedy
Dealers will replace the seatbelt pretensioner(s), free of charge. Owner notification letters were mailed May 3, 2022. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC231. This recall is replaced by NHTSA recall number 22V-447. Vehicles already repaired under this recall will need to have the new remedy completed.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Fuel pipe connection may leak
Reported July 8, 2021Model years 2021NHTSA campaign 21V51900021,575 vehicles affected
Fuel may leak at the connection between the high-pressure fuel pump and fuel rail, increasing fire risk. Dealers will inspect and tighten or replace the fuel pipe as necessary, free of charge.
Official NHTSA recall text
Component
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Defect
Kia Motor America (Kia) is recalling certain 2021 Sorento and 2021-2022 K5 vehicles equipped with 2.5L turbocharged engines. Fuel may leak at the pipe connection between the high-pressure fuel pump and fuel rail.
Consequence
A fuel leak increases the risk of a fire.
Remedy
Dealers will inspect and tighten, or replace the fuel pipe as necessary, free of charge. Owner notification letters were mailed July 21, 2021. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC214.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Brake fluid leak may cause an electrical short
Reported May 10, 2021Model years 2014–2015NHTSA campaign 21V331000440,370 vehicles affected
Park outside: the maker advises parking affected vehicles outdoors, away from buildings, until they are repaired.
Brake fluid may leak inside the hydraulic control unit and cause an electrical short, increasing fire risk while parked or driving. Dealers will install a new multi-fuse and inspect for leaks, replacing the control unit if needed, free of charge.
Official NHTSA recall text
Component
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE
Defect
Kia Motors America (Kia) is recalling certain 2013-2015 Optima and 2014-2015 Sorento vehicles previously recalled under recall 20V-519. Brake fluid may leak inside the Hydraulic Electronic Control Unit (HECU), possibly resulting in an electrical short.
Consequence
An electrical short in the HECU increases the risk of a fire while parked or driving.
Remedy
Owners are advised to park outside and away from other vehicles and structures until the recall repair is completed. Dealers will install a new multi-fuse, and inspect the HECU for leaks, replacing the HECU if necessary, free of charge. Owner notification letters were mailed on July 2, 2021. This recall supersedes previous NHTSA recall number 20V-519. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC212.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
eCall may not transmit the VIN
Reported February 1, 2021Model years 2020DVSA recall R/2021/002965 vehicles affected
When eCall is activated, the VIN may not be transmitted. The eCall system will be reset so it transmits the VIN accurately.
Official DVSA recall text
Component
IF THE ECALL SYSTEM IS ACTIVATED THE VIN NUMBER MAY NOT BE TRANSMITTED
Defect
If the eCall system is activated the VIN number may not be transmitted.
Remedy
Reset the eCall system so that the VIN number is transmitted accurately when appropriate.
Engine compartment fire may occur
Reported December 2, 2020Model years 2012–2013NHTSA campaign 20V750000294,756 vehicles affected
An engine compartment fire may occur while driving, increasing the risk of injury. Dealers will inspect for fuel or oil leaks, test the engine, make any needed repairs including engine replacement, and update the detection software, free of charge.
Official NHTSA recall text
Component
ENGINE
Defect
Kia Motors America (Kia) is recalling certain 2012-2013 Sorento, 2012-2015 Forte and Forte Koup, 2011-2013 Optima Hybrid, 2014-2015 Soul, and 2012 Sportage vehicles. An engine compartment fire can occur while driving.
Consequence
An engine compartment fire increases the risk of injury.
Remedy
Kia will notify owners, and dealers will inspect the engine compartment for fuel and/or engine oil leaks, perform an engine test and make any repairs, including engine replacement, as necessary, free of charge. In addition, Kia dealers will update the Knock Sensor Detection System (KSDS) software, free of charge. The recall began January 27, 2021. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC200.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Low-pressure fuel line may leak
Reported October 16, 2020Model years 2020EU Safety Gate A12/01909/20
An inadequately assembled low-pressure fuel line hose connection may leak fuel and cause a fire. The product is recalled from end users.
Official EU Safety Gate text
Component
Fire
Defect
The assembly of the low pressure fuel line hose connection is inadequate and may cause a fuel leakage and fire. /
Remedy
Recall of the product from end users
Notes
Notified by Poland
Brake fluid leak may cause HECU electrical short
Reported August 27, 2020Model years 2014–2015NHTSA campaign 20V519000440,370 vehicles affected
Park outside: the maker advises parking affected vehicles outdoors, away from buildings, until they are repaired.
Brake fluid may leak inside the HECU and cause an electrical short, increasing the risk of an engine compartment fire. Dealers will inspect the HECU and replace it if necessary, free of charge.
Official NHTSA recall text
Component
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE
Defect
Kia Motors America (Kia) is recalling certain 2013-2015 Optima and 2014-2015 Sorento vehicles. Brake fluid may leak inside the Hydraulic Electronic Control Unit (HECU), possibly resulting in an electrical short.
Consequence
If the HECU short circuits, there is an increased risk of an engine compartment fire.
Remedy
Kia will notify owners, and dealers will inspect the HECU for leaking brake fluid and replace the HECU if necessary, free of charge. Owners are advised to park outside and away from other vehicles and structures until the recall repair is completed. The recall began October 20, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC197.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Water or oil may cause a short circuit in the HECU
Reported July 20, 2020Model years 2005–2008DVSA recall R/2020/187EU Safety Gate A12/00995/2031,290 vehicles affected
Water or oil may enter the hydraulic electronic control unit over time and cause an electrical short circuit. A relay will be installed to isolate the unit when the ignition is off.
Official DVSA recall text
Component
WATER OR OIL MAY ENTER THE HYDRAULIC ELECTRONIC CONTROL UNIT
Defect
Water or oil may enter the Hydraulic Electronic Control Unit over a long period of time causing an electrical short circuit.
Remedy
Install a relay to isolate the HECU when the ignition is switched off.
Moisture in ABS module may cause an electrical short
Reported February 14, 2020Model years 2007–2009NHTSA campaign 20V088000228,829 vehicles affected
Moisture may enter the ABS module and cause an electrical short, which can start an engine compartment fire even when the vehicle is off. Dealers will install a relay in the main junction box free of charge.
Official NHTSA recall text
Component
ELECTRICAL SYSTEM
Defect
Kia Motors America (Kia) is recalling certain 2006-2010 Sedona and 2007-2009 Sorento vehicles. Moisture may enter the Anti-lock Brake (ABS) Module and result in an electrical short.
Consequence
An electrical short within the ABS Module may cause an engine compartment fire, even when the vehicle is turned off, increasing the risk of an injury.
Remedy
Kia will notify owners, and dealers will install a relay in the main junction box to prevent power from being directed to the HECU when the vehicle's ignition switch is turned off, free of charge. The recall began June 5, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC186.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Collision avoidance system may miss pedestrians
Reported January 13, 2020Model years 2019DVSA recall R/2019/455579 vehicles affected
The forward collision avoidance system may have problems identifying pedestrians. Dealers will upgrade the multi-function camera software.
Official DVSA recall text
Component
IN SOME SITUATIONS THE FRONT COLLISION AVOIDANCE SYSTEM MAY NOT RECOGNISE PEDESTRIANS
Defect
The Forward Collision Avoidance Assist system may have problems identifying pedestrians.
Remedy
Upgrade the software for the Multi-Function Camera system.
High-pressure fuel pipe may leak
Reported December 19, 2018Model years 2012–2017NHTSA campaign 18V90700071,653 vehicles affected
The high-pressure fuel pipe may be damaged, misaligned or improperly tightened, causing a fuel leak that can increase the risk of fire. Dealers will inspect and replace the pipe as needed, free of charge.
Official NHTSA recall text
Component
ENGINE
Defect
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
Consequence
A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy
Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Steering column crossbar may separate
Reported September 21, 2018Model years 2018NHTSA campaign 18V65600097 vehicles affected
The cowl crossbar may be improperly welded and allow the steering column to separate, causing loss of steering and increasing crash risk. Dealers will replace the crossbar free of charge.
Official NHTSA recall text
Component
STEERING:ELECTRIC POWER ASSIST SYSTEM
Defect
Kia Motors America (Kia) is recalling certain 2018 Kia Sorento vehicles. The cowl crossbar that connects to the Motor Driven Power Steering (MDPS) steering column may be improperly welded, allowing the steering column to separate.
Consequence
If the steering column separates, it can cause a loss of steering ability, increasing the risk of a crash.
Remedy
Kia will notify owners, and dealers will replace the cowl crossbar, free of charge. The recall began October 26, 2018. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC167.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Side curtain airbag component may detach
Reported December 8, 2017Model years 2018NHTSA campaign 17V7840002,014 vehicles affected
A component may detach when a side curtain airbag deploys and enter the cabin as a projectile, increasing injury risk. Dealers will replace both side curtain airbags free of charge.
Official NHTSA recall text
Component
AIR BAGS:SIDE/WINDOW
Defect
Kia Motors America (Kia) is recalling certain 2018 Kia Sorento vehicles. The side curtain air bags on these vehicles have a component that may detach during deployment of the inflatable curtain air bag.
Consequence
If the component detaches during deployment, it may enter the passenger compartment and be a projectile within the vehicle cabin, increasing the risk of injury.
Remedy
Kia will notify owners, and dealers will replace the driver and passenger side curtain air bags, free of charge. The recall began on December 18, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC159.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Diesel fuel feed pipe may crack and leak
Reported November 23, 2017Model years 2011DVSA recall R/2017/28024 vehicles affected
The diesel fuel feed pipe to the high-pressure pump may deteriorate, harden and crack, leaking fuel onto the engine and creating a fire risk. The fuel feed hose will be replaced.
Official DVSA recall text
Component
RUBBER DIESEL FUEL FEED PIPE MAY HARDEN OR CRACK
Defect
The diesel fuel feed pipe that supplies fuel to the high pressure pump may deteriorate prematurely. The customer may initially notice the smell of diesel fuel leaking onto the engine. If the concern is not resolved the rubber hose may harden and crack due to fatigue. This in turn could allow the pipe to leak diesel fuel onto the engine. As with all fuel leaks there is a risk of catching fire.
Remedy
Recall the 24 vehicles that are likely to be affected and replace the fuel feed hose.
Crankshaft may fail and stall the engine
Reported September 21, 2017Model years 2017NHTSA campaign 17V58600062 vehicles affected
The crankshaft may fail because it was improperly heat treated. Failure can stall the engine, increasing crash risk, and also increases fire risk. Dealers will inspect the crankshaft and replace the engine sub assembly as needed, free of charge.
Official NHTSA recall text
Component
ENGINE AND ENGINE COOLING:ENGINE
Defect
Kia Motors America (Kia) is recalling certain 2017 Sorento vehicles equipped with 3.3L engines. The engine crankshaft may have been improperly heat treated and may fail.
Consequence
If the crankshaft fails, the engine will stall, increasing the risk of a crash. A failed crankshaft also increases the risk of a fire.
Remedy
Kia will notify owners, and dealers will inspect the crankshaft, and, as necessary, replace the engine sub assembly, free of charge. The recall began November 6, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC153.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Engine bearings may wear prematurely
Reported March 31, 2017Model years 2012–2014NHTSA campaign 17V224000618,160 vehicles affected
Machining errors may cause premature engine bearing wear, which may seize the engine and increase crash risk. Dealers will inspect the engine assembly and replace the engine if necessary, free of charge.
Official NHTSA recall text
Component
ENGINE AND ENGINE COOLING:ENGINE
Defect
Kia Motor Company (Kia) is recalling certain 2011-2014 Optima, 2012-2014 Sorento and 2011-2013 Sportage vehicles. Machining errors during the engine manufacturing process may cause premature bearing wear within the engine.
Consequence
Bearing wear may result in the engine seizing, increasing the risk of a crash.
Remedy
Kia will notify owners, and dealers will inspect the engine assembly, and replace the engine if necessary, free of charge. The recall began June 20, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC147.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Trailer brake lights may stay illuminated
Reported November 30, 2016Model years 2016–2017NHTSA campaign 16V86200010,212 vehicles affected
A fault in the trailer hitch module may keep the trailer brake lights illuminated, confusing other drivers and increasing crash risk. Dealers will replace the trailer tow hitch harness free of charge.
Official NHTSA recall text
Component
TRAILER HITCHES
Defect
Kia Motors America (Kia) is recalling certain model year 2016-2017 Sorento vehicles manufactured October 27, 2014, to August 25, 2016, and 2017 Sportage vehicles manufactured December 10, 2015, to August 26, 2016. The affected vehicles are equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence
If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy
Kia will notify owners, and dealers will replace the trailer tow hitch harness, free of charge. The recall began January 18, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC142.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Driver seatback frame welds may fail
Reported October 24, 2016Model years 2016NHTSA campaign 16V7700001,408 vehicles affected
Inadequate welds may allow the driver's seatback frame to break in a crash and fail to restrain the occupant, increasing injury risk. Dealers will inspect the welds and replace the frame as needed, free of charge.
Official NHTSA recall text
Component
SEATS
Defect
Kia Motors America (Kia) is recalling certain model year 2016 Kia Sorento vehicles manufactured March 3, 2016 to March 21, 2016. The driver's seatback frame may have been produced with inadequate weld joints and, as a result, the seatback may not function as designed in the event of a rear-end collision.
Consequence
In the event of a crash, the driver seatback frame could break and fail to restrain a seat occupant, increasing the risk of injury.
Remedy
Kia will notify owners, and dealers will inspect the welds and replace the driver seatback frame, as necessary, free of charge. The recall began on December 9, 2016. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC140.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Rear suspension weld may break
Reported June 29, 2016Model years 2016NHTSA campaign 16V4800007,901 vehicles affected
A rear suspension weld may break, affecting alignment and increasing crash risk. Dealers will inspect the welds and replace the rear cross-member assembly as needed, free of charge.
Official NHTSA recall text
Component
SUSPENSION:REAR
Defect
Kia Motors America (Kia) is recalling certain model year 2016 Sorento vehicles. A component of the rear suspension may not be properly welded.
Consequence
The improper weld may break, affecting the rear suspension alignment, thereby increasing the risk of a crash.
Remedy
Kia will notify owners, and dealers will inspect the welds at the rear suspension cross-member, replacing the rear cross-member assembly, as necessary, free of charge. The recall began July 27, 2016. Owners may contact Kia Customer Service Department at 1-800-333-4542. Kia's number for this recall is SC137.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Brake-shift interlock may allow shifting out of Park
Reported October 6, 2015Model years 2011–2013NHTSA campaign 15V626000377,062 vehicles affected
The brake-shift interlock may chip or crack, allowing the transmission to shift out of Park without pressing the brake. The vehicle could roll and cause a crash. Dealers will replace the interlock free of charge.
Official NHTSA recall text
Component
POWER TRAIN:AUTOMATIC TRANSMISSION
Defect
Kia Motors America (Kia) is recalling certain model year 2011-2013 Kia Sorento vehicles manufactured October 19, 2009, to January 31, 2013. In the affected vehicles, if excessive force is applied to the gear shift lever, the brake-shift interlock mechanism may chip or crack allowing the transmission being able to be shifted out of "Park" without the brakes being depressed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection."
Consequence
Without requiring the brake to be pressed, the vehicle may be unintentionally shifted out of Park, allowing it to roll, which may result in a crash.
Remedy
Kia will notify owners, and dealers will replace the brake-shift interlock mechanism, free of charge. The recall began on November 9, 2015. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC124.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Front passenger seat belt buckle may not latch
Reported July 14, 2015Model years 2016NHTSA campaign 15V4460002,587 vehicles affected
The front passenger seat belt buckle may prevent the belt from fastening, increasing the risk of injury in a crash. Dealers will replace the buckle cover free of charge.
Official NHTSA recall text
Component
SEAT BELTS:FRONT:BUCKLE ASSEMBLY
Defect
Kia Motors America (Kia) is recalling certain model year 2016 Kia Sorento vehicles manufactured October 23, 2014, to December 10, 2014. The affected vehicles have a front passenger seat belt whose buckle latch assembly may prevent the front passenger from fastening the seat belt.
Consequence
If the front passenger seat belt cannot be latched, an occupant sitting in the front passenger seat has an increased risk of injury in the event of a crash.
Remedy
Kia will notify owners, and dealers will replace the front passenger seat belt buckle cover, free of charge. The recall began on August 18, 2015. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC123.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Accelerator pedal may not accelerate vehicle
Reported February 13, 2015Model years 2016NHTSA campaign 15V08900012,361 vehicles affected
A poorly soldered part in the accelerator pedal assembly may prevent the vehicle from accelerating, increasing crash risk. Dealers will replace the accelerator assembly, free of charge.
Official NHTSA recall text
Component
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
Defect
Kia Motors America (Kia) is recalling certain model year 2016 Sorento vehicles manufactured October 27, 2014, to January 29, 2015. Due to an improperly soldered component in the accelerator pedal assembly, the driver may not be able to accelerate the vehicle.
Consequence
If the vehicle is unable to be accelerated, there is an increased risk of a crash.
Remedy
Kia will notify owners, and dealers will replace the accelerator assembly, free of charge. The recall began on February 19, 2015. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC115.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Driver seat belt pretensioner piston may separate
Reported May 9, 2014EU Safety Gate A12/0709/14
In a crash, the driver seat belt anchor pretensioner piston may separate from the cable after activation, reducing the protection provided to the driver. The product is being recalled from end users.
Official EU Safety Gate text
Component
Injuries
Defect
null In the event of a crash, the driver seat belt anchor pretensioner piston may separate from the cable immediately after the pretensioner activation. This would reduce the protection afforded to the driver.
Remedy
Recall of the product from end users
Notes
Notified by Greece
Right front axle shaft may fracture
Reported August 13, 2013Model years 2014NHTSA campaign 13V3560009,345 vehicles affected
The right front axle shaft may fracture, causing loss of power to the wheels or allowing the vehicle to roll if parked without the parking brake applied. Dealers will replace the axle shaft assembly free of charge.
Official NHTSA recall text
Component
POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT
Defect
Kia Motors Corp. is recalling certain model year 2014 front wheel drive Sorento vehicles manufactured January 7, 2013, through March 12, 2013; and equipped with 2.4 liter engines. Due to a manufacturing issue, the right front axle shaft may fracture.
Consequence
A fractured front axle may result in a loss of power to the wheels. Additionally, if the vehicle is parked without the parking brake applied, it may roll away. Either condition increases the risk of a crash.
Remedy
Kia will notify owners, and dealers will replace the front axle shaft assembly, free of charge. The recall began on September 9, 2013. Owners may contact Kia at 1-800-333-4542 . Kia's recall number is SC099.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Brake light switch fault may affect brake lights
Reported June 1, 2013Model years 2007–2011DVSA recall R/2013/055326,152 vehicles affected
Carbonised contacts in the brake light switch may cause the brake lights to work intermittently and may affect ESC, cruise control, gear selection in automatic vehicles and the engine check lamp. The switch will be replaced.
Official DVSA recall text
Component
BRAKE LIGHTS MAY MALFUNCTION
Defect
The vehicles brake lights may intermittently malfunction due to carbonisation of the contacts within the brake light switch. This can also affect other systems on the vehicle including: ESC cruise control gear selection (autoboxes) engine check lamp.
Remedy
Recall vehicles likely to be affected to replace the brake light switch.
Brake light switch may malfunction
Reported April 1, 2013Model years 2007–2011NHTSA campaign 13V114000980,377 vehicles affected
A faulty switch may keep brake lights from illuminating, prevent cruise control from disengaging, affect push-button start or the shift interlock, or turn on the ESC warning light. The shifter may move out of Park without the brake applied, risking unintended movement. Dealers will replace the switch free of charge.
Official NHTSA recall text
Component
EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
Defect
Kia Motors Corporation (Kia) is recalling certain model year 2007-2010 Rondo, model year 2007-2011 Sedona, Sorento and Sportage, model year 2010-2011 Soul, model year 2008-2011 Optima, model year 2010 Forte, model year 2007-2009 Amanti, and model year 2009 Borrego vehicles. Originally, in April 2013, Kia recalled 623,658 model year 2007-2010 Rondo and Sportage, model year 2007-2011 Sorento, model year 2007 Sedona, model year 2010-2011 Soul, and model year 2011 Optima vehicles. In September 2013, Kia informed the agency that it was adding an additional 356,719 vehicles to this campaign. The total number of vehicles being recalled is now 980,377. In the affected vehicles, the stop lamp switch may malfunction. A malfunctioning stop lamp switch may cause the brake lights to not illuminate when the brake pedal is depressed or may cause an inability to deactivate the cruise control by depressing the brake pedal. Additionally, a malfunctioning stop lamp switch may also result in intermittent operation of the push-button start feature, affect the operation of the brake-transmission shift interlock feature preventing the shifter from being moved out of the PARK position and cause the Electronic Stability Control (ESC) malfunction light to illuminate.
Consequence
Failure to illuminate the stop lamps during braking or inability to disengage the cruise control could increase the risk of a crash. Additionally, when the ignition is in the 'ON' position, the transmission shifter may be able to be moved out of PARK without first applying the brake. This may lead to unintentional movement of the car which may increase the risk of a crash.
Remedy
Kia will send an interim notification to owners in May 2013. When parts are available, owners will receive a second notification and dealers will replace the stop lamp switch, free of charge. Owners may contact Kia at 1-800-333-4542. Kia's recall campaign number is SC098.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Passenger air bag may turn off for an adult
Reported September 7, 2011Model years 2007–2008NHTSA campaign 11V47300010,631 vehicles affected
The occupant classification system may mistake an adult passenger for a child or child seat and turn off the passenger air bag. The passenger could lack air bag protection in some frontal crashes, increasing injury risk. The system control module will be reprogrammed at no charge.
Official NHTSA recall text
Component
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE
Defect
KIA IS RECALLING CERTAIN MODEL YEAR 2007-2008 SORENTO PASSENGER CARS MANUFACTURED FROM JUNE 15, 2006 THROUGH NOVEMBER 27, 2007. THE FRONT PASSENGER AIR BAG MAY BE TURNED OFF WHEN AN ADULT IS IN THE PASSENGER SEAT. THE FRONT PASSENGER AIR BAG IS DESIGNED TO BE TURNED OFF IN LIMITED CIRCUMSTANCES INCLUDING WHEN CHILDREN AND SMALL ADULTS ARE SEATED IN THE FRONT PASSENGER SEAT, THERE IS A CHILD RESTRAINT IN THAT SEAT OR THE SEAT IS NOT OCCUPIED. THE VEHICLE'S OCCUPANT CLASSIFICATION SYSTEM (OCS), WHICH CLASSIFIES THE OCCUPANT IN THE FRONT PASSENGER SEAT, MAY MISCLASSIFY AN ADULT PASSENGER AS A CHILD OR CHILD SEAT AND IMPROPERLY TURN OFF THE PASSENGER SIDE AIR BAG. WHEN THE AIR BAG IS DEACTIVATED THE "PASSENGER AIR BAG OFF" LIGHT WILL ILLUMINATE ON THE CENTER INSTRUMENT PANEL.
Consequence
THE PASSENGER SIDE AIR BAG IS TURNED OFF WHEN THE OCS MISCLASSIFIES AN ADULT PASSENGER. WITH THE FRONT PASSENGER AIRBAG OFF, THE FRONT PASSENGER WILL NOT HAVE THE PROTECTION OF THE PASSENGER AIR BAGS IN SOME FRONTAL COLLISIONS, THUS INCREASING THE RISK OF OCCUPANT INJURY.
Remedy
KIA WILL UPDATE THE PROGRAMMING IN THE SORENTO OCS CONTROL MODULE AT NO CHARGE. THE RECALL REMEDY IS CURRENTLY AVAILABLE UNDER SERVICE CAMPAIGN SC076. OWNERS MAY CONTACT KIA CUSTOMER SERVICE AT 1-800-333-4542.
Notes
KIA'S RECALL CAMPAIGN NUMBER IS SC076A.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Misaligned intermediate shaft may damage transmission
Reported April 25, 2011Model years 2011NHTSA campaign 11V25800012,690 vehicles affected
Misalignment with the right side output gear may cause noise and excessive wear in the intermediate shaft, eventually damaging the transmission and possibly causing loss of motive power. Dealers will replace the output gear and intermediate shaft free of charge.
Official NHTSA recall text
Component
POWER TRAIN:DRIVELINE:DRIVESHAFT
Defect
KIA IS RECALLING CERTAIN MODEL YEAR 2011 SORENTO 2WD VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND 2.4L ENGINES MANUFACTURED FROM THE START OF PRODUCTION THROUGH MAY 22, 2010. THE INTERMEDIATE SHAFT MAY SUFFER FROM NOISE AND EXCESSIVE WEAR DUE TO A MISALIGNMENT OF THE INTERMEDIATE SHAFT WITH THE RIGHT SIDE OUTPUT GEAR. CONTINUING TO DRIVE THE VEHICLE IN THIS CONDITION LEADS TO THE DEVELOPMENT OF A WHIRRING/WHINING NOISE AND CAN EVENTUALLY CAUSE DAMAGE TO THE AUTOMATIC TRANSMISSION.
Consequence
DAMAGE TO THE TRANSMISSION MAY CAUSE LOSS OF MOTIVE POWER, INCREASING THE RISK OF A CRASH.
Remedy
DEALERS WILL REPLACE THE RIGHT SIDE OUTPUT GEAR AND INTERMEDIATE SHAFT FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MAY 2011. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
Notes
KIA SAFETY RECALL NO. SC089.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
Rear brake caliper may leak fluid
Reported November 24, 2010Model years 2011NHTSA campaign 10V5990007,697 vehicles affected
An improperly machined rear brake caliper may leak fluid, causing a warning light and a soft or spongy brake pedal. If not serviced, braking power may be reduced, increasing crash risk. Dealers will inspect the rear calipers and replace them if needed, free of charge.
Official NHTSA recall text
Component
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER
Defect
KIA IS RECALLING CERTAIN MODEL YEAR 2011 SORENTO VEHICLES MANUFACTURED FROM SEPTEMBER 14, 2010, THROUGH OCTOBER 4, 2010. SOME OF THE REAR BRAKE CALIPERS MAY NOT HAVE BEEN PROPERLY MACHINED.
Consequence
AS A RESULT, BRAKE FLUID WILL LEAK, FOLLOWED BY ILLUMINATION OF THE MALFUNCTION INDICATOR LIGHT INDICATING THE BRAKE FLUID LEVEL IS LOW AND SHOULD BE CHECKED, THEN A SOFT OR SPONGY BRAKE PEDAL FEEL, AND IF NOT SERVICED, REDUCED BRAKING POWER WHICH COULD INCREASE THE RISK OF A CRASH.
Remedy
DEALERS WILL INSPECT THE REAR CALIPERS AND REPLACE IT IF NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. OWNERS MAY CONTACT KIA CONSUMER ASSISTANCE CENTER AT 1-800-333-4542.
Notes
KIA'S SAFETY RECALL CAMPAIGN NUMBER IS SC087.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
Door mood lighting wiring may overheat
Reported September 7, 2010Model years 2009–2010DVSA recall R/2010/129549 vehicles affected
The door mood lighting wiring may overheat in use, creating a potential fire risk. The wiring will be replaced.
Official DVSA recall text
Component
RISK OF FIRE
Defect
The wiring to the mood lighting in the doors may overheat in use and if ignored there is a potential risk of fire.
Remedy
Recalled vehicles to have the wiring to the mood lights replaced.
Lighting wiring harness may short
Reported August 31, 2010Model years 2011NHTSA campaign 10V38800035,185 vehicles affected
Improperly soldered wiring for the door lighting may short under certain conditions and cause a fire. Dealers will replace the affected wiring harnesses free of charge.
Official NHTSA recall text
Component
ELECTRICAL SYSTEM:WIRING
Defect
KIA IS RECALLING CERTAIN MODEL YEAR 2010 SOUL AND MODEL YEAR 2011 SORENTO VEHICLES MANUFACTURED FROM SEPTEMBER 7, 2009 THROUGH JULY 30, 2010. A LIMITED NUMBER OF WIRING HARNESSES SUPPLIED BY JCI AND USED FOR THE LIGHTING IN THE KIA SOUL VEHICLE'S ADVANCED LIGHTING SPEAKERS, LOCATED IN THE FRONT DOOR TRIM PANELS, AND THE KIA SORENTO VEHICLE'S INTERIOR ACCENT ILLUMINATION, LOCATED IN THE FRONT AND REAR DOOR TRIM PANELS, MAY HAVE BEEN IMPROPERLY SOLDERED.
Consequence
WHEN THE LIGHTS ARE ILLUMINATED UNDER CERTAIN CONDITIONS, AN ELECTRICAL SHORT MAY OCCUR THAT CAN RESULT IN A FIRE.
Remedy
DEALERS WILL REPLACE THE WIRING HARNESSES FOR THE LIGHTS IN THE KIA SOUL VEHICLE'S ADVANCED LIGHTING SPEAKERS, AND THE WIRING HARNESS FOR THE KIA SORENTO VEHICLE'S INTERIOR ACCENT ILLUMINATION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 13, 2010. OWNERS MAY CONTACT KIA CONSUMER ASSISTANCE CENTER AT 1-800-333-4542.
Notes
KIA'S SAFETY RECALL CAMPAIGN NUMBER IS SC083.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
Brake lights may not operate
Reported November 9, 2009Model years 2009–2006DVSA recall R/2009/0927,264 vehicles affected
A faulty switch may prevent the brake lights from operating when the brake pedal is pressed. The brake light switch will be replaced.
Official DVSA recall text
Component
BRAKE LIGHT MAY NOT OPERATE
Defect
It has been identified that due to a faulty switch the brake lights may not operate when the brake pedal is depressed
Remedy
Recalled vehicles will have the brake light switch replaced.
Stop lamp switch may malfunction
Reported April 17, 2009Model years 2006–2007NHTSA campaign 09V130000139,844 vehicles affected
A faulty stop lamp switch may prevent brake lights from working or leave them on, affect shifting out of Park, illuminate the stability control warning light, or prevent cruise control from disengaging when braking. These faults may lead to a crash. Dealers will replace the switch free of charge.
Official NHTSA recall text
Component
EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
Defect
HUYNDAI-KIA IS RECALLING 139,844 MY 2006-2007- SEDONA, SPORTAGE, SORENTO AND MY RONDO AND AMANTI VEHICLES. THE STOP LAMP SWITCH IN THE AFFECTED VEHICLES MAY MALFUNCTION. A MALFUNCTIONING STOP LAMP SWITCH MAY CAUSE THE BRAKE LIGHTS TO NOT ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED OR MAY CAUSE THE BRAKE LIGHTS TO REMAIN ILLUMINATED WHEN THE BRAKE PEDAL IS RELEASED. A STOP LAMP SWITCH MALFUNCTION MAY ALSO AFFECT THE OPERATION OF THE BRAKE-TRANSMISSION SHIFT INTERLOCK FEATURE SO THE TRANSMISSION SHIFTER WOULD NOT BE ABLE TO BE SHIFTED OUT OF THE PARK POSITION. IT MAY ALSO CAUSE THE ELECTRONIC STABILITY CONTROL (ESC) MALFUNCTION LIGHT TO ILLUMINATE, AND IT MAY NOT DEACTIVATE THE CRUISE CONTROL WHEN THE BRAKE PEDAL IS DEPRESSED.
Consequence
ANY OF THESE MALFUNCTIONS, ALONE OR IN COMBINATION, MAY LEAD TO A CRASH.
Remedy
DEALERS WILL REPLACE THE STOP LAMP SWITCH FREE OF CHARGE. THE RECALL BEGAN ON JUNE 17, 2009. OWNERS MAY CONTACT KIA'S CONSUMER ASSISTANCE CENTER AT 1-800-333-4542.
Notes
HYUNDAI-KIA RECALL NO. SC077.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
Curtain airbags may deploy incorrectly
Reported May 14, 2007Model years 2006–2007DVSA recall R/2007/0771,864 vehicles affected
Wires to the airbag control unit may be in the wrong order, causing the wrong side curtain airbag to deploy in a collision. The connector pins will be refitted in the correct order.
Official DVSA recall text
Component
CURTAIN AIRBAGS MAY DEPLOY INCORRECTLY
Defect
It has been identified that some of the wires to the airbag control unit are not in the correct order. In consequence an incorrect side curtain airbag could deploy in the event of a collision.
Remedy
Recalled vehicles will have the pins on the connector to the control unit refitted in the correct order.
Fuel tubes may leak near the tank
Reported August 4, 2005Model years 2003NHTSA campaign 05V3530002,935 vehicles affected
Fuel tubes near the tank may rub against the vehicle floor and leak. Fuel reaching an ignition source could cause a fire. Dealers will replace a section of the fuel line.
Official NHTSA recall text
Component
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Defect
CERTAIN SPORT UTILITY VEHICLES MAY EXPERIENCE A FUEL LEAK FROM FUEL TUBES NEAR THE FUEL TANK DUE TO AN INTERFERENCE FIT WITH THE VEHICLE FLOOR PANEL.
Consequence
FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy
DEALERS WILL REPLACE A SECTION OF THE FUEL LINE. THE RECALL BEGAN ON OCTOBER 10, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
Notes
KIA RECALL NO. SC-052.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
Gearbox reverse gear snap ring may break
Reported November 8, 2004Model years 2003–2004DVSA recall R/2004/1591,148 vehicles affected
The snap ring retaining reverse gear may break, reducing power transfer and potentially allowing the vehicle to roll forward while in reverse. A modified transmission unit will be fitted.
Official DVSA recall text
Component
SNAP RING RETAINER WITHIN THE GEARBOX MAY DETACH
Defect
The snap ring which retains the reverse gear may break which may result in poor power transfer. Should this occur the vehicle may roll forward whilst in reverse gear.
Remedy
Recall likely to be affected vehicles and fit a modified transmission unit.
Alternator pulley may seize
Reported November 8, 2004Model years 2002–2004DVSA recall R/2004/1583,517 vehicles affected
The alternator pulley may seize and cause the drive belt to be lost, increasing the effort needed to steer and press the brake pedal. The pulley will be replaced with a modified part.
Official DVSA recall text
Component
ALTERNATOR PULLEY MAY SEIZE
Defect
The alternator pulley may seize resulting in the loss of the drive belt. This in turn can result in an increased physical effort requirement for both the steering and brake pedal
Remedy
Affected vehicles will be recalled at which time the pulley will be replaced with a modified item.
Power steering hose may chafe brake pipe
Reported July 5, 2004Model years 2002–2004DVSA recall R/2004/0774,427 vehicles affected
The power steering hose may contact and chafe the metal brake pipe, potentially causing fluid loss. The gap will be checked and adjusted, and the brake pipe replaced if needed.
Official DVSA recall text
Component
POSSIBLE INTERFERENCE BETWEEN POWER STEERING HOSE AND BRAKE PIPE
Defect
It is possible that the power steering hose could come in contact with the metal brake pipe. If unchecked there is potential for the metal brake pipe to chafe which could result in fluid loss.
Remedy
Return the vehicle to the dealers to check and adjust the gap between the power steering hose and metal brake pipe. And if required replace the metal brake pipe.

Sources: NHTSA (US National Highway Traffic Safety Administration), DVSA (UK Driver and Vehicle Standards Agency) and the EU Safety Gate (European Commission) recall data. Each recall covers vehicles sold in that market; models sold elsewhere may differ.

Back to the Kia Sorento

Instrument cluster may reset or display a green image

Instrument panel display may fail

Incorrect spare tire may affect braking systems

HVAC blower wiring harness may cause a fire

Connecting rod bolts may cause engine failure

Daytime running light may stay off

Software error may disable low beams and taillights

Steering rack may damage fuel line in a crash

Brake control unit may overheat

Power steering wiring harness may cause loss of assist

Engine compartment fire may occur while driving

HECU may short circuit and cause fire

Turn signals may not activate intermittently

Water may enter rearview camera and disable image

Rearview camera mounting clips may break

Air bag warning labels may detach

Fuel tank may leak

PTC heater may overheat and pose a fire risk

Fuel tank may leak

Transmission oil pump may develop an internal fault

Gear shift lever may move out of Park without the brake

Transmission fault may cause loss of drive power

Tow hitch wiring may short circuit

Shift lever may not lock

Incorrect spare tyre may impair ABS and traction control

Seat belt pretensioner may explode when deployed

Diesel fuel line may leak

Front left seat belt pretensioner may be faulty

PTC heater connector may overheat

Turbocharger oil supply pipe may crack and leak

Front seat belt pretensioners may explode

Fuel pipe connection may leak

Brake fluid leak may cause an electrical short

eCall may not transmit the VIN

Engine compartment fire may occur

Low-pressure fuel line may leak

Brake fluid leak may cause HECU electrical short

Water or oil may cause a short circuit in the HECU

Moisture in ABS module may cause an electrical short

Collision avoidance system may miss pedestrians

High-pressure fuel pipe may leak

Steering column crossbar may separate

Side curtain airbag component may detach

Diesel fuel feed pipe may crack and leak

Crankshaft may fail and stall the engine

Engine bearings may wear prematurely

Trailer brake lights may stay illuminated

Driver seatback frame welds may fail

Rear suspension weld may break

Brake-shift interlock may allow shifting out of Park

Front passenger seat belt buckle may not latch

Accelerator pedal may not accelerate vehicle

Driver seat belt pretensioner piston may separate

Right front axle shaft may fracture

Brake light switch fault may affect brake lights

Brake light switch may malfunction

Passenger air bag may turn off for an adult

Misaligned intermediate shaft may damage transmission

Rear brake caliper may leak fluid

Door mood lighting wiring may overheat

Lighting wiring harness may short

Brake lights may not operate

Stop lamp switch may malfunction

Curtain airbags may deploy incorrectly

Fuel tubes may leak near the tank

Gearbox reverse gear snap ring may break

Alternator pulley may seize

Power steering hose may chafe brake pipe