Tesla Model Y recalls

50 official safety recalls for the Tesla Model Y from NHTSA (United States), DVSA (United Kingdom) and the EU Safety Gate, newest first. Recall repairs are normally free at the maker’s dealers.

Whether your car is affected and still needs the repair depends on its VIN or registration. Check it on the official site for your country:

United States: nhtsa.gov/recalls
United Kingdom: check-vehicle-recalls.service.gov.uk

Front suspension fasteners may loosen
Reported August 31, 2026Model years 2026NHTSA campaign 26V55800019 vehicles affected
Loose lateral link fasteners may allow a link to loosen or separate, shifting wheel alignment and causing loss of control. Tesla Service will tighten or replace the fasteners, check alignment and replace damaged related parts as needed, free of charge.
Official NHTSA recall text
Component
SUSPENSION:FRONT
Defect
Tesla, Inc. (Tesla) is recalling certain 2026 Model Y vehicles. One or more front suspension lateral link fasteners may not have been properly tightened, allowing the lateral link to loosen or separate from the sub-frame.
Consequence
A lateral link separation could shift the wheel alignment, causing a loss of vehicle control and increasing the risk of a crash.
Remedy
Tesla Service will tighten or replace the fasteners and check wheel the alignment, free of charge. In addition, Tesla Service will replace any related parts that may have been damaged as necessary. Owner notification letters are expected to be mailed October 30, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-26-31-004.
Headlight low beams may be too bright
Reported August 4, 2026Model years 2020–2023NHTSA campaign 26V50700020,349 vehicles affected
The low beams may exceed the maximum light output and reduce visibility for oncoming drivers, increasing crash risk. The headlights will be replaced free of charge.
Official NHTSA recall text
Component
EXTERIOR LIGHTING:HEADLIGHTS
Defect
Tesla, Inc. (Tesla) is recalling certain 2017-2023 Model 3 and 2020-2023 Model Y vehicles. The headlight low beams may be too bright and exceed the maximum light output. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence
Headlight low beams that are too bright can reduce visibility for oncoming drivers, increasing the risk of a crash.
Remedy
Tesla Service will replace the headlights, free of charge. Owner notification letters are expected to be mailed October 3, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-17-003.
Missing safety features may reduce occupant protection
Reported July 7, 2026Model years 2026NHTSA campaign 26V44500015 vehicles affected
The vehicles may lack knee airbags and other interior safety features and may not meet bumper impact requirements. Occupant protection may be reduced in a crash, increasing injury risk. The vehicles will be repurchased free of charge.
Official NHTSA recall text
Component
STRUCTURE:BODY:BUMPERS
Defect
Tesla, Inc. (Tesla) is recalling certain 2026 Model Y and 2024 Model 3 vehicles. The vehicles were originally built for a foreign market and do not have knee air bags, may not be equipped with certain interior safety countermeasures, and may not have been tested for bumper impact resistance procedures. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers, 208, "Occupant Crash Protection," 201, "Occupant Protection in Interior Impact," and Part 581, "Bumper Standards."
Consequence
A noncompliant vehicle may have reduced occupant protections, increasing the risk of injury during a crash.
Remedy
Tesla will repurchase noncompliant vehicles currently registered in the United States, free of charge. Owner notification letters are expected to be mailed September 5, 2026. Owners may contact Tesla customer service at 1-877-798-3752 or resolutions@tesla.com. Tesla's number for this recall is SB-26-00-004.
Certification label may be missing
Reported May 18, 2026Model years 2025–2026NHTSA campaign 26V31500014,575 vehicles affected
The certification label may be missing. Without its weight information, the vehicle could be unintentionally overloaded, increasing crash risk. Tesla Service will inspect and install a label as necessary, free of charge.
Official NHTSA recall text
Component
EQUIPMENT:OTHER:LABELS
Defect
Tesla, Inc. (Tesla) is recalling certain 2025-2026 Model Y vehicles. The certification label may not have been installed. As such, these vehicles fail to comply with the requirements of 49 C.F.R. Part 567, "Certification."
Consequence
Missing weight information provided by the label may lead to unintentionally overloading the vehicle, increasing the risk of a crash.
Remedy
Tesla Service will inspect and install a certification label as necessary, free of charge. Owner notification letters were mailed July 17, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-26-19-002.
Rearview camera image may be delayed
Reported May 4, 2026Model years 2020–2023NHTSA campaign 26V283000218,868 vehicles affected
The rearview camera image may be delayed when shifting into reverse, reducing the driver's view behind the vehicle and increasing crash risk. A free over-the-air software update is available.
Official NHTSA recall text
Component
BACK OVER PREVENTION:SOFTWARE
Defect
Tesla, Inc. (Tesla) is recalling certain 2017, 2021-2023 Model 3, 2020-2023 Model Y, 2021-2023 Model S, and Model X vehicles operating software version 2026.8.6. The rearview camera image may be delayed when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence
A delayed rearview image reduces the driver's view behind the vehicle, increasing the risk of a crash.
Remedy
Tesla has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed July 3, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-26-00-001.
Reverse lamps may fail to illuminate
Reported October 16, 2025Model years 2025DVSA recall R/2025/4222 vehicles affected
One or both reverse lamps may not switch on when reverse gear is selected because of a break in the rear lamp circuit. The rear lamp housing and wiring will be inspected, and defective parts repaired or replaced as needed.
Official DVSA recall text
Component
Loss of Reverse Light Recall
Defect
On affected vehicles one or both reverse lamps may fail to switch on when the driver selects reverse gear due to a loss of continuity in the rear lamp circuit.
Remedy
Inspect rear lamp housing and wiring harness and repair or replace the defective components as necessary.
Battery contactors may fail
Reported October 10, 2025Model years 2026NHTSA campaign 25V69000012,963 vehicles affected
The battery pack contactors may fail, causing a loss of drive power and increasing crash risk. Tesla Service will replace the contactors free of charge.
Official NHTSA recall text
Component
ELECTRICAL SYSTEM:PROPULSION SYSTEM:FUSES, RELAYS, CONTACTS, AND SHUNTS
Defect
Tesla, Inc. (Tesla) is recalling certain 2025 Model 3 and 2026 Model Y vehicles. The battery pack contactors may fail, causing a loss of drive power.
Consequence
A loss of drive power can increase the risk of a crash.
Remedy
Tesla Service will replace the battery pack contactors, free of charge. Owner notification letters were mailed December 9, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-25-16-005.
Reverse lights may fail to illuminate
Reported October 1, 2025Model years 2026NHTSA campaign 25V658000260 vehicles affected
A wiring defect may prevent the reverse lights from illuminating, reducing visibility and failing to alert others that the vehicle is backing up. This increases crash risk. Tesla Service will replace the reverse lights and reverse fascia harness free of charge.
Official NHTSA recall text
Component
ELECTRICAL SYSTEM:WIRING
Defect
Tesla, Inc. (Tesla) is recalling certain 2026 Model Y vehicles. The reverse lights may fail to illuminate while the vehicle is in reverse, due to a defect in the wiring. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence
Reverse lights that fail to illuminate reduce visibility and may not alert pedestrians or other drivers that the vehicle is backing up, increasing the risk of a crash.
Remedy
Tesla Service will replace the reverse lights and reverse facia harness, free of charge. Owner notification letters were mailed November 26, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-25-17-011.
Right front window may not auto-reverse as required
Reported September 24, 2025Model years 2025DVSA recall R/2025/3505,777 vehicles affected
Firmware that enables high-speed sampling of the right front window motor encoder was not enabled, so the window may not meet auto-reversing requirements. Modified software will be installed by over-the-air update.
Official DVSA recall text
Component
Update Vehicle Firmware to Remedy Anti Pinch Feature of Right Front Window
Defect
On affected vehicles a firmware feature that allowed for high-speed sampling of the right front window motor encoder was not enabled bringing vehicles out of compliance with the relevant regulations for Auto-reversing Requirements.
Remedy
Install modified software via an Over the Air (OTA) update.
Horn may not sound
Reported July 28, 2025Model years 2026NHTSA campaign 25V4900006 vehicles affected
An improperly secured horn ground wire terminal may open the circuit and prevent the horn from sounding, increasing crash risk. Tesla service will replace the steering wheel, free of charge.
Official NHTSA recall text
Component
ELECTRICAL SYSTEM:HORN
Defect
Tesla, Inc. (Tesla) is recalling certain 2026 Model Y vehicles. The ring terminal of the horn ground wire may be improperly secured, allowing the circuit to open and preventing the horn from sounding.
Consequence
An inoperable horn may prevent the driver from alerting other drivers as needed, increasing the risk of a crash.
Remedy
Tesla service will replace the steering wheel, free of charge. Owner notification letters were be mailed September 23, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-25-17-009.
Seat back fasteners may be loose
Reported June 18, 2025Model years 2026NHTSA campaign 25V41000048 vehicles affected
Improperly tightened fasteners attaching the seat back to the seat bottom may prevent the seat from properly restraining an occupant in a crash, increasing injury risk. Service centres will inspect and tighten or replace the fasteners as necessary, free of charge.
Official NHTSA recall text
Component
SEATS:CRITICAL FASTENERS
Defect
Tesla, Inc. (Tesla) is recalling certain 2026 Model 3 and Model Y vehicles. The fasteners attaching the seat back to the seat bottom may have been improperly tightened.
Consequence
The seat may not properly restrain the occupant, increasing the risk of injury during a crash.
Remedy
Tesla Service Centers will inspect and tighten or replace the seat assembly fasteners as necessary, free of charge. Owner notification letters were mailed August 16, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-25-13-003.
Washer hose connector may block the nozzles
Reported May 29, 2025Model years 2026NHTSA campaign 25V359000172 vehicles affected
The hose connector may block the windshield washer nozzles, preventing fluid from reaching the windshield and reducing visibility. Service will inspect and replace the wiper arm elbow connector as needed, free of charge.
Official NHTSA recall text
Component
VISIBILITY:WINDSHIELD WIPER/WASHER:LINKAGES
Defect
Tesla, Inc. (Tesla) is recalling certain 2026 Model Y vehicles. The hose connector may block the windshield washer nozzles, preventing washer fluid from reaching the windshield. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 104, "Windshield Wiping and Washing Systems."
Consequence
The inability to clean the windshield reduces the driverâs visibility and increases the risk of a crash.
Remedy
Tesla service will inspect and replace the wiper arm elbow connector as necessary, free of charge. Owner notification letters were mailed July 25, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-25-20-001.
Rearview camera display may be lost
Reported March 28, 2025Model years 2024DVSA recall R/2025/04910,629 vehicles affected
A short in the car computer board during power-up may cause the rearview camera to stop working. An over-the-air software update will be applied, or the car computer will be replaced if necessary.
Official DVSA recall text
Component
Loss of Rearview Camera Display Recall
Defect
On a small percentage of affected vehicles upon vehicle power up the car computer board may experience a short resulting in the loss of rear view camera functionality .
Remedy
Over the air software update or Car Computer replacement if necessary.
Steering assistance may be lost after stopping
Reported March 14, 2025Model years 2022–2023DVSA recall R/2025/10497,462 vehicles affected
An overvoltage may overstress steering rack motor components. Steering assistance remains while driving, but may be lost at a standstill and remain unavailable when driving again; a visual alert may appear. Manual steering remains available. Modified software will be installed by wireless update.
Official DVSA recall text
Component
Update Vehicle Software To Rectify EPAS Functionality
Defect
On affected vehicles operating with a software release prior to 2023.38.4 an overvoltage breakdown in the steering rack may overstress motor drive components on the printed circuit board. If the overstress condition occurs while the vehicle is driving steering assistance will not be affected and a visual alert will illuminate. Once the vehicle speed comes to a standstill a loss of steering assistance may occur and loss of steering assistance will persist when the vehicle is driven again. Manual steering without steering assistance remains available to the driver.
Remedy
Install modified software via an Over the Air (OTA) wireless update.
Power steering assist may be lost
Reported February 14, 2025Model years 2023NHTSA campaign 25V092000376,241 vehicles affected
The steering assist circuit board may become overstressed, causing loss of power steering assist after stopping and accelerating again. Greater steering effort, especially at low speeds, can increase crash risk. A software update is available over the air, free of charge.
Official NHTSA recall text
Component
STEERING:ELECTRIC POWER ASSIST SYSTEM
Defect
Tesla, Inc. (Tesla) is recalling certain 2023 Model 3 and Model Y vehicles operating software prior to 2023.38.4. The printed circuit board for the electronic power steering assist may experience an overstress condition, causing a loss of power steering assist when the vehicle reaches a stop and then accelerates again.
Consequence
A loss of power steering assist can require greater steering effort, especially at low speeds, increasing the risk of a crash.
Remedy
Tesla has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed March 25, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-25-00-004.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 888-275-9171) or go to nhtsa.gov.
Computer circuit board may fail, disabling rearview camera
Reported January 6, 2025Model years 2023–2025NHTSA campaign 25V002000239,382 vehicles affected
A computer circuit board may short and cause the rearview camera image to disappear, reducing the driver's rear view and increasing the risk of a crash. A free over-the-air software update is available; computers with a failure or stress that could lead to failure will be replaced, free of charge.
Official NHTSA recall text
Component
BACK OVER PREVENTION:SOFTWARE
Defect
Tesla, Inc. (Tesla) is recalling certain 2024-2025 Model 3, Model S, 2023-2025 Model X, and Model Y vehicles. The computer circuit board may short, resulting in the loss of the rearview camera image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence
A rearview camera that does not display an image reduces the driver's rear view, increasing the risk of a crash.
Remedy
Tesla released an over-the-air (OTA) software update, free of charge. Tesla will also identify any vehicles that experienced a circuit board failure, or stress that may lead to a circuit board failure, and replace the affected computers, free of charge. Owner notification letters were mailed March 7, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-25-00-001.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153) or go to nhtsa.gov.
Tyre pressure warning may not persist
Reported December 31, 2024Model years 2021–2024DVSA recall R/2025/00262,893 vehicles affected
After a TPMS malfunction, the warning may disappear when the vehicle is switched off, leaving the driver unaware of under-inflated tyres and increasing collision risk. Modified software will be installed by over-the-air update.
Official DVSA recall text
Component
Update vehicle software to correct TPMS behaviour
Defect
On affected vehicles upon detection of a malfunction with the tyre pressure monitoring system (TPMS) the TPMS tell tale does not persist between drive cycles where the vehicle is off or asleep between the drive cycles. Therefore the driver may not be adequately warned of potential under-inflation of the tyres increasing the risk of a collision.
Remedy
Install modified software via an Over the Air (OTA) wireless update.
Tire pressure warning light may not stay on
Reported December 17, 2024Model years 2020–2025NHTSA campaign 24V935000696,281 vehicles affected
The tire pressure warning light may turn off between drives and fail to alert the driver to low tire pressure. Driving on improperly inflated tires increases crash risk. A software update is available over the air free of charge.
Official NHTSA recall text
Component
TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS
Defect
Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck, 2017-2025 Model 3, and 2020-2025 Model Y vehicles. The tire pressure monitoring system (TPMS) warning light may not remain illuminated between drive cycles, failing to warn the driver of low tire pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."
Consequence
Driving with improperly inflated tires increases the risk of a crash.
Remedy
Tesla released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 15, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-018.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Front seat recliner weld may fail
Reported November 22, 2024Model years 2024NHTSA campaign 24V88600027 vehicles affected
The weld attaching the recliner mechanism to the front seat back may fail, so the seat may not properly restrain an occupant in a crash, increasing injury risk. Tesla service will replace the seat assembly, free of charge.
Official NHTSA recall text
Component
SEATS:FRONT ASSEMBLY:RECLINER
Defect
Tesla, Inc. (Tesla) is recalling certain 2024 Model Y vehicles. The weld attaching the seat recliner mechanism to the front seat backs may fail.
Consequence
The seat back frame may not properly restrain the occupant during a crash, increasing the risk of injury.
Remedy
Tesla service will replace the seat assembly, free of charge. Owner notification letters were mailed January 21, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-13-004.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153) or go to nhtsa.gov.
Hood latch may not detect an unlatched hood
Reported July 24, 2024Model years 2020–2024NHTSA campaign 24V5540001,849,638 vehicles affected
The hood latch system may fail to detect that the hood is unlatched after it has been opened. The hood could open while driving, block the driver's view and increase crash risk. A software update is available over the air free of charge.
Official NHTSA recall text
Component
ELECTRICAL SYSTEM:SOFTWARE
Defect
Tesla, Inc. (Tesla) is recalling certain 2021-2024 Model 3, Model S, Model X, and 2020-2024 Model Y vehicles. The hood latch assembly may fail to detect an unlatched hood condition after the hood has been opened.
Consequence
An unlatched hood can fully open, obstructing the driver's view and increasing the risk of a crash.
Remedy
Tesla has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed September 24, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-012.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Seat belt warning may fail to alert an unbelted driver
Reported May 28, 2024Model years 2020–2023NHTSA campaign 24V376000125,233 vehicles affected
The seat belt warning light and audible chime may not activate as intended when the driver is unbelted, increasing injury risk in a crash. The manufacturer will release an over-the-air software update.
Official NHTSA recall text
Component
SEAT BELTS:FRONT:WARNING LIGHT/DEVICES
Defect
Tesla, Inc. (Tesla) is recalling certain 2012-2024 Model S, 2015-2024 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles. In the event of an unbelted driver, the seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence
A seat belt warning system that fails to alert occupants of an unbelted seat belt can increase the risk of injury during a crash.
Remedy
Tesla will release an over-the-air (OTA) software update. Owner notification letters were mailed July 26, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-008.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Pedestrian warning sounds may be muted
Reported February 27, 2024Model years 2020–2022NHTSA campaign 24V1530006,557 vehicles affected
A factory reset may mute the pedestrian warning sounds, making an approaching vehicle harder for pedestrians to hear and increasing crash risk. A software update is available free of charge.
Official NHTSA recall text
Component
FORWARD COLLISION AVOIDANCE: WARNINGS:EXTERNAL/PEDESTRIAN ALERT
Defect
Tesla, Inc. (Tesla) is recalling certain 2013, 2018-2021 Model S, 2020-2021 Model X, 2018-2022 Model 3, and 2020-2022 Model Y vehicles. A factory reset muted the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Consequence
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are muted, increasing the risk of a crash.
Remedy
Tesla released an over-the-air (OTA) software update, release 2023.44.30.14, free of charge. Owner notification letters were mailed April 27, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-006.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Brake warning lights may be too small
Reported January 30, 2024Model years 2019–2024NHTSA campaign 24V0510002,193,869 vehicles affected
The instrument panel may display the Brake, Park and ABS warning lights in a font that is too small, making critical safety information difficult to read and increasing crash risk. An over-the-air software update is available free of charge.
Official NHTSA recall text
Component
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
Defect
Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric Brake Systems" and 135, "Light Vehicle Brake Systems."
Consequence
Warning lights with a smaller font size can make critical safety information on the instrument panel difficult to read, increasing the risk of a crash.
Remedy
Tesla began releasing an over-the-air (OTA) software update, free of charge. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-003.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Rearview camera image may not display
Reported January 22, 2024Model years 2023NHTSA campaign 24V035000199,575 vehicles affected
Software instability may prevent the rearview camera image from displaying, reducing visibility while reversing and increasing crash risk. An over-the-air software update is available free of charge.
Official NHTSA recall text
Component
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Defect
Tesla, Inc. (Tesla) is recalling certain 2023 Model S, X, and Y vehicles equipped with full self-driving computer 4.0 and running a software release version 2023.44.30 through 2023.44.30.6 or 2023.44.100. Software instability may prevent the rearview camera image from displaying.
Consequence
A rearview image that does not display while in reverse decreases the driver's visibility and increases the risk of a crash.
Remedy
Tesla has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed March 22, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-002.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Driver assistance controls may not prevent misuse
Reported December 12, 2023Model years 2020–2023NHTSA campaign 23V8380002,031,220 vehicles affected
When Autosteer is engaged, its controls may not be prominent or comprehensive enough to prevent misuse. A driver who is unprepared to take over or does not realise the feature has disengaged may be at increased risk of a crash. Tesla will provide a software update over the air free of charge.
Official NHTSA recall text
Component
ELECTRICAL SYSTEM:ADAS:DRIVER MONITORING:SOFTWARE
Defect
Tesla, Inc. (Tesla) is recalling 2012-2023 Model S, 2016-2023 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with all versions of Autosteer leading up to the version(s) that contains the recall remedy. In certain circumstances when Autosteer is engaged, the prominence and scope of the feature's controls may not be sufficient to prevent driver misuse of the SAE Level 2 advanced driver-assistance feature.
Consequence
In certain circumstances when Autosteer is engaged, and the driver does not maintain responsibility for vehicle operation and is unprepared to intervene as necessary or fails to recognize when Autosteer is canceled or not engaged, there may be an increased risk of a crash.
Remedy
Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 10, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-008.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Forward camera may disable safety features
Reported July 14, 2023Model years 2023NHTSA campaign 23V4890001,337 vehicles affected
A misaligned forward-facing camera may disable emergency braking, forward collision warning or lane assist without alerting the driver, increasing crash risk. Tesla Service will inspect and adjust the camera pitch angle as needed, free of charge.
Official NHTSA recall text
Component
FORWARD COLLISION AVOIDANCE: SENSING SYSTEM: CAMERA
Defect
Tesla, Inc. (Tesla) is recalling certain 2023 Model S, Model X, and Model Y vehicles. The forward-facing camera may be misaligned, causing some of the active safety features such as emergency braking, forward collision warning, and lane assist to become unavailable without alerting the driver.
Consequence
Safety features that are unavailable without any warning to the driver may increase the risk of a crash.
Remedy
Tesla Service will inspect and adjust the pitch angle, as necessary, free of charge. Owner notification letters were mailed September 12, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-17-006.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Battery disconnect may not isolate high voltage
Reported June 19, 2023Model years 2023NHTSA campaign 23V43400026 vehicles affected
A defective pyrotechnic battery disconnect may fail to isolate the high voltage battery after a crash or fault, increasing the risk of electric shock and injury. Tesla Service will replace the disconnect free of charge.
Official NHTSA recall text
Component
ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY
Defect
Tesla, Inc. (Tesla) is recalling certain 2023 Model 3 and Model Y vehicles. The pyrotechnic battery disconnect may be defective.
Consequence
A defective battery disconnect may not isolate the vehicle's high voltage battery after a crash or fault detection, increasing the risk of electrical shock and injury.
Remedy
Tesla Service will replace the pyrotechnic battery disconnect, free of charge. Owner notification letters were mailed August 18, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-16-005.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Steering wheel fastener may be loose
Reported May 30, 2023Model years 2022–2023NHTSA campaign 23V385000137 vehicles affected
A loose steering wheel fastener may allow the wheel to disconnect from the steering column, causing loss of steering control and increasing the risk of a crash. Service will inspect and replace the fastener as necessary, free of charge.
Official NHTSA recall text
Component
STEERING:CRITICAL FASTENERS
Defect
Tesla, Inc. (Tesla) is recalling certain 2022-2023 Model Y vehicles. The steering wheel fastener may be loose.
Consequence
A loose fastener may allow the steering wheel to disconnect from the steering column, which can cause a loss of steering control and increase the risk of a crash.
Remedy
Tesla Service will inspect and replace the fastener as necessary, free of charge. Owner notification letters were be mailed July 28, 2023. Tesla's number for this recall is SB-23-32-001.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Second-row seat back bolts may be loose
Reported February 27, 2023Model years 2022–2023NHTSA campaign 23V1300003,470 vehicles affected
Bolts securing the second-row seat back frames may be loose, reducing seat belt performance and increasing the risk of injury in a crash. Service centres will inspect and tighten the bolts as necessary, free of charge.
Official NHTSA recall text
Component
SEAT BELTS:REAR/OTHER:ANCHORAGE
Defect
Tesla, Inc. (Tesla) is recalling certain 2022-2023 Model Y vehicles. The bolts securing the second-row seat back frames may not have been securely tightened.
Consequence
A loose seat frame bolt may reduce the seat belt system's performance, increasing the risk of injury during a crash.
Remedy
Tesla Service Centers will inspect and tighten the bolts as necessary, free of charge. Owner notification letters are expected to be mailed April 25, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-13-001.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Driver assistance software may act unsafely at intersections
Reported February 15, 2023Model years 2020–2023NHTSA campaign 23V085000362,758 vehicles affected
The software may allow the vehicle to travel straight from a turn-only lane, enter a stop sign-controlled intersection without stopping, or proceed at a steady yellow signal without due caution. It may also respond inadequately to speed limits or the driver's speed setting. These behaviours increase crash risk. Tesla will provide a software update free of charge.
Official NHTSA recall text
Component
STEERING:AUTOMATED/ADAPTIVE STEERING
Defect
Tesla, Inc. (Tesla) is recalling certain 2016-2023 Model S, Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with Full Self-Driving Beta (FSD Beta) software or pending installation.Â The FSD Beta system may allow the vehicle to act unsafe around intersections, such as traveling straight through an intersection while in a turn-only lane, entering a stop sign-controlled intersection without coming to a complete stop, or proceeding into an intersection during a steady yellow traffic signal without due caution. In addition, the system may respond insufficiently to changes in posted speed limits or not adequately account for the driver's adjustment of the vehicle's speed to exceed posted speed limits.
Consequence
FSD Beta software that allows a vehicle to exceed speed limits or travel through intersections in an unlawful or unpredictable manner increases the risk of a crash.
Remedy
Tesla will release an over-the-air (OTA) software update, free of charge.Â Owner notification letters were mailed April 15, 2023.Â Owners may contact Tesla customer service at 1-877-798-3752.Â Tesla's number for this recall is SB-23-00-001.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Front suspension fasteners may be loose
Reported December 5, 2022Model years 2023NHTSA campaign 22V89500026 vehicles affected
Front suspension lateral link fasteners may not be properly attached to the sub-frame. A link may separate, causing instability and increasing crash risk. Tesla Service will tighten or replace the fasteners as needed, free of charge.
Official NHTSA recall text
Component
SUSPENSION:CRITICAL FASTENERS
Defect
Tesla, Inc. (Tesla) is recalling certain 2023 Model Y vehicles. The front suspension lateral link fasteners may not have been properly attached to the sub-frame.
Consequence
A loose fastener can allow the lateral link to separate from the sub-frame, causing instability and increasing the risk of a crash.
Remedy
Tesla Service will tighten or replace the fasteners as necessary, free of charge. Owner notification letters were mailed February 7, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-31-002.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153) or go to www.nhtsa.gov.
Taillights may intermittently fail to illuminate
Reported November 15, 2022Model years 2020–2023NHTSA campaign 22V844000321,628 vehicles affected
One or both taillights may stop working intermittently, reducing the vehicle’s visibility and increasing crash risk. A free over-the-air software update is available.
Official NHTSA recall text
Component
EXTERIOR LIGHTING:TAIL LIGHTS
Defect
Tesla, Inc. (Tesla) is recalling certain 2023 Model 3 and 2020-2023 Model Y vehicles. One or both taillights may intermittently fail to illuminate.
Consequence
A taillight that fails to illuminate may reduce the visibility of the vehicle, increasing the risk of a crash.
Remedy
Tesla has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed January 14, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-016.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Power window may exert excessive force
Reported September 19, 2022Model years 2020–2022NHTSA campaign 22V7020001,096,762 vehicles affected
The automatic window reversal system may not respond correctly to an obstruction. A closing window may pinch an occupant with excessive force before retracting, increasing injury risk. Tesla will update the software over the air free of charge.
Official NHTSA recall text
Component
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
Defect
Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3, 2020-2022 Model Y, and 2021-2022 Model S and Model X vehicles. The window automatic reversal system may not react correctly after detecting an obstruction. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 118, "Power-Operated Window Systems."
Consequence
A closing window may exert excessive force by pinching a driver or passenger before retracting, increasing the risk of injury.
Remedy
Tesla will perform an over-the-air (OTA) software update of the automatic window reversal system, free of charge. Owner notification letters were mailed March 31, 2032. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-013.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Camera views may be swapped
Reported May 9, 2022Model years 2021NHTSA campaign 22V3170007 vehicles affected
Incorrectly installed camera cable terminals may swap camera views, preventing detection of crossing objects and curved lane lines and impairing driver assistance and automatic emergency braking. Service will correct the terminals and recalibrate the cameras free of charge.
Official NHTSA recall text
Component
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Defect
Tesla, Inc. (Tesla) is recalling certain 2020-2021 Model 3 and 2021 Model Y vehicles. The fisheye and narrow camera cable terminals were incorrectly installed in the cable harness connector, resulting in swapped camera views.
Consequence
Swapped camera views can prevent the vehicle's cameras from detecting crossing objects and high-curvature lane lines, impairing the Autosteer and Automatic Emergency Braking (AEB) performance, and increasing the risk of a crash.
Remedy
Tesla Service will correct the swapped terminals and recalibrate the cameras, free of charge. Owner notification letters were mailed July 8, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-17-007.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Infotainment computer may overheat
Reported May 3, 2022Model years 2022NHTSA campaign 22V296000129,960 vehicles affected
The infotainment computer may overheat during fast charging and lag or restart, preventing the centre screen from showing the rearview camera image, gear selection, visibility controls, or warning lights. A free over-the-air software update will improve temperature management.
Official NHTSA recall text
Component
EQUIPMENT:ELECTRICAL:INFOTAINMENT:VIDEO (TOUCH)SCREEN/MONITOR/UNIT
Defect
Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model S, Model X, and 2022 Model 3 and Model Y vehicles operating certain firmware releases. The infotainment central processing unit (CPU) may overheat during the preparation or process of fast-charging, causing the CPU to lag or restart.
Consequence
A lagging or restarting CPU may prevent the center screen from displaying the rearview camera image, gear selection, windshield visibility control settings, and warning lights, increasing the risk of a crash.
Remedy
Tesla will perform an over-the-air (OTA) software update that will improve CPU temperature management, free of charge. Owner notification letters were mailed July 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-009.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Audio system may become unavailable
Reported April 19, 2022Model years 2021DVSA recall R/2022/13118,942 vehicles affected
Loss of low-voltage system support may disable the audio system, including eCall audio. Firmware release 2022.12.3 or later reverses the power management change and maintains eCall audio functionality.
Official DVSA recall text
Component
A LOSS OF LOW VOLTAGE SYSTEM SUPPORT MAY CAUSE THE AUDIO SUBSYSTEM TO BE UNAVAILABLE
Defect
On certain vehicles that are running firmware release 2022.8 and that experience a loss of low voltage system support the audio subsystem may become unavailable including the use of eCall functionality.
Remedy
Firmware release 2022.12.3 or later reverses the power management process introduced in firmware release 2022.8 and maintains eCall audio functionality.
Boombox sounds may obscure pedestrian warnings
Reported April 12, 2022Model years 2020–2022NHTSA campaign 22V235000594,894 vehicles affected
The Boombox function may play sounds outside the vehicle while it is moving and obscure pedestrian warning sounds. Pedestrians may not hear an approaching vehicle, increasing crash risk. An over-the-air software update will disable Boombox in Drive, Neutral and Reverse, including Summon and Smart Summon, free of charge.
Official NHTSA recall text
Component
ELECTRICAL SYSTEM:SOFTWARE
Defect
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model Y, Model X, Model S, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Consequence
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Remedy
Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, including Summon and Smart Summon, free of charge. Owner notification letters were mailed June 6, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall supersedes recall 22V-063. Vehicles configured with Summon or Smart Summon and already remedied under 22V-063 will need to have the new remedy software installed.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
External sounds may obscure pedestrian warning
Reported February 4, 2022Model years 2020–2022NHTSA campaign 22V063000578,607 vehicles affected
The Boombox function may play sounds that obscure the pedestrian warning system while the vehicle is moving, making it harder for pedestrians to hear an approaching vehicle. Tesla will disable Boombox in Drive, Neutral and Reverse with a free over-the-air software update.
Official NHTSA recall text
Component
FORWARD COLLISION AVOIDANCE: WARNINGS:EXTERNAL/PEDESTRIAN ALERT
Defect
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model S, Model X, Model Y, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."
Consequence
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
Remedy
Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, free of charge. Owner notification letters are expected to be mailed April 5, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall has been superseded by Recall 22V-235. Tesla's number for the new recall is SB-22-00-003.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Heat pump software may reduce defrosting
Reported February 2, 2022Model years 2020–2022NHTSA campaign 22V05000026,681 vehicles affected
A software error may cause a heat pump valve to open unexpectedly and trap refrigerant in the evaporator, reducing defrosting performance and visibility. Tesla will provide a free over-the-air software update.
Official NHTSA recall text
Component
ELECTRICAL SYSTEM:SOFTWARE
Defect
Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model 3, Model S, Model X, and 2020-2022 Model Y vehicles. A software error may cause a valve in the heat pump to open unintentionally and trap the refrigerant inside the evaporator, resulting in decreased defrosting performance. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 103, "Windshield Defrosting and Defogging Systems."
Consequence
Decreased defrosting performance may reduce the driver's visibility, increasing the risk of a crash.
Remedy
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-18-002.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Seat belt warning chime may not sound
Reported February 1, 2022Model years 2020–2022NHTSA campaign 22V045000817,143 vehicles affected
The warning chime may not sound when the vehicle starts and the driver's seat belt is unfastened, so the driver may not realise the belt is not fastened. Tesla will provide a free over-the-air software update.
Official NHTSA recall text
Component
SEAT BELTS:FRONT
Defect
Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The audible chime may not activate when the vehicle starts and the driver has not buckled their seat belt. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence
The driver may be unaware that their seat belt is not fastened, increasing the risk of injury during a crash.
Remedy
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-002.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Rolling stop feature may skip stop signs
Reported January 27, 2022Model years 2020–2022NHTSA campaign 22V03700053,822 vehicles affected
The rolling stop function may let the vehicle pass through an all-way stop without stopping, increasing crash risk. Tesla will disable the function with a free over-the-air software update.
Official NHTSA recall text
Component
STEERING:AUTOMATED/ADAPTIVE STEERING
Defect
Tesla, Inc. (Tesla) is recalling certain 2016-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The "rolling stop" functionality available as part of the Full Self-Driving (Beta) software may allow the vehicle to travel through an all-way stop intersection without first coming to a stop.
Consequence
Failing to stop at a stop sign can increase the risk of a crash.
Remedy
Tesla will perform an over-the-air (OTA) software update that disables the "rolling stop" functionality, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-001.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Front suspension lateral link bolts may be under-torqued
Reported December 24, 2021Model years 2020–2021DVSA recall R/2022/006254 vehicles affected
The front suspension lateral link bolts may be under-torqued. Both links' sub-frame connections will be inspected; damaged related parts will be replaced and the bolts correctly tightened.
Official DVSA recall text
Component
THE FRONT SUSPENSION LATERAL LINK MAY BE INSUFFICIENTLY TORQUED
Defect
The front suspension lateral link may be insufficiently torqued.
Remedy
Inspect the connection of both front suspension lateral links to the sub-frame. Replace any related damaged components and ensure correct torque of fastening bolts.
Suspension knuckles may fracture and separate links
Reported November 21, 2021Model years 2020–2022NHTSA campaign 21V912000826 vehicles affected
The front or rear suspension knuckles may fracture, allowing suspension links to separate and reducing stability and control, which increases the risk of a crash. Tesla Service will inspect and replace the knuckles as necessary, free of charge.
Official NHTSA recall text
Component
SUSPENSION
Defect
Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model Y vehicles. The front and rear suspension knuckles may fracture, causing the suspension links to separate.
Consequence
Suspension links that separate can reduce vehicle stability and control, increasing the risk of a crash.
Remedy
Tesla Service will inspect and replace the knuckles as necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-31-004.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Software error may activate automatic emergency braking
Reported October 29, 2021Model years 2020–2021NHTSA campaign 21V84600011,728 vehicles affected
A communication error may cause false forward-collision warnings or unexpected automatic emergency braking. Sudden stopping may increase crash risk. Tesla Service has released an over-the-air software update, free of charge.
Official NHTSA recall text
Component
FORWARD COLLISION AVOIDANCE:SOFTWARE
Defect
Tesla, Inc. (Tesla) is recalling certain 2017-2021 Model S, Model 3, Model X, and 2020-2021 Model Y vehicles operating software version 2021.36.5.2. A communication error may cause false forward-collision warning (FCW) or unexpected activation of the automatic emergency brake (AEB) system.
Consequence
Unexpected activation of the AEB system may cause the car to stop suddenly, increasing the risk of a crash.
Remedy
Tesla Service has released an over-the-air (OTA) software update, free of charge. The recall began October 25, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-00-004.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Front suspension fasteners may loosen
Reported October 25, 2021Model years 2020–2021NHTSA campaign 21V8350002,791 vehicles affected
Loose fasteners may let a front suspension lateral link separate from the sub-frame, shifting wheel alignment and causing instability that increases crash risk. Tesla Service will tighten or replace the fasteners as needed, free of charge.
Official NHTSA recall text
Component
SUSPENSION:FRONT
Defect
Tesla, Inc. (Tesla) is recalling certain 2020-2021 Model Y and 2019-2021 Model 3 vehicles. The front suspension lateral link fasteners may loosen, allowing the lateral link to separate from the sub-frame.
Consequence
A lateral link separation could shift the wheel alignment, causing instability and increasing the risk of a crash.
Remedy
Tesla Service will tighten or replace the lateral link fasteners as necessary, free of charge. Owner notification letters were mailed December 20, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-31-003.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Front seat belt fasteners may be loose
Reported May 25, 2021Model years 2019–2021NHTSA campaign 21V3890005,530 vehicles affected
Fasteners securing a front shoulder belt to the B-pillar may not be properly attached, preventing the seat belt system from working as designed and increasing injury risk. Tesla Service will inspect and repair both fasteners if needed, free of charge.
Official NHTSA recall text
Component
SEAT BELTS:CRITICAL FASTENERS
Defect
Tesla, Inc. (Tesla) is recalling certain 2018-2020 Model 3 and 2019-2021 Model Y vehicles. One or both fasteners that secure the front seat shoulder belt to the b-pillar may not be properly attached.
Consequence
An improperly attached fastener may prevent the seat belt system from performing as designed, increasing the risk of injury.
Remedy
Tesla Service will inspect and repair both fasteners if necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-20-001.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Rear seat belt retractor fasteners may be loose
Reported May 25, 2021Model years 2019–2021NHTSA campaign 21V3880002,166 vehicles affected
Fasteners securing the second-row seat belt retractors may not be properly attached, preventing the seat belt system from working as designed and increasing injury risk. Tesla Service will inspect and replace both fasteners if needed, free of charge.
Official NHTSA recall text
Component
SEAT BELTS:CRITICAL FASTENERS
Defect
Tesla, Inc. (Tesla) is recalling certain 2019-2021 Model Y vehicles. One or both fasteners that secure the left and right second row seat belt retractors may not be properly attached.
Consequence
Improperly attached fasteners may prevent the seat belt retention system from performing as designed, increasing the risk of injury.
Remedy
Tesla Service will inspect and replace both fasteners if necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-20-002.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Brake caliper bolts may loosen
Reported May 25, 2021Model years 2020–2021NHTSA campaign 21V3870005,974 vehicles affected
Loose brake caliper bolts may let the caliper separate and contact the wheel rim, causing loss of tyre pressure and increasing crash risk. Tesla Service will inspect and tighten or replace the bolts as needed, free of charge.
Official NHTSA recall text
Component
SERVICE BRAKES, HYDRAULIC:CRITICAL FASTENERS
Defect
Tesla, Inc. (Tesla) is recalling certain 2019-2021 Model 3 and 2020-2021 Model Y vehicles. The brake caliper bolts may be loose, allowing the brake caliper to separate and contact the wheel rim.
Consequence
Contact with the rim may cause a loss of tire pressure, increasing the risk of a crash.
Remedy
Tesla Service will inspect and tighten, or replace the caliper bolts as necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-33-002.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Front upper control arm bolts may loosen
Reported November 17, 2020Model years 2020NHTSA campaign 20V709000401 vehicles affected
Loose bolts may let the front upper control arm detach from the steering knuckle, causing the wheels to lean and reducing steering control, which increases crash risk. Dealers will inspect and tighten the bolts as necessary, free of charge.
Official NHTSA recall text
Component
SUSPENSION:FRONT:CONTROL ARM
Defect
Tesla, Inc. (Tesla) is recalling certain 2020 Model Y vehicles. The bolts connecting the front upper control arm and steering knuckle may have not been properly tightened, allowing the upper control arm to detach from the steering knuckle.
Consequence
A detached upper control arm can cause the wheels to lean in or out, decreasing the driver's ability to steer and increasing the risk of a crash.
Remedy
Tesla will notify owners, and dealers will inspect, and as necessary, tighten the bolts, free of charge. The recall began January 15, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-20-31-012.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Trailer brake lights may not illuminate
Reported September 30, 2020Model years 2020NHTSA campaign 20V6090002,567 vehicles affected
A software error may prevent trailer brake lights from illuminating during braking, increasing the risk of a crash. A firmware update has been released over the air.
Official NHTSA recall text
Component
EXTERIOR LIGHTING:BRAKE LIGHTS
Defect
Tesla, Inc. (Tesla) is recalling certain 2020 Model Y vehicles equipped with a global rear lamp and tow package configuration. A software error prevents the illumination of trailer brake lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence
Trailer brake lights that fail to illuminate during braking increase the risk of a crash.
Remedy
Tesla will notify owners, and has released the firmware update over-the-air (OTA) to vehicles as of September 23, 2020. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-20-00-002.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Sources: NHTSA (US National Highway Traffic Safety Administration), DVSA (UK Driver and Vehicle Standards Agency) and the EU Safety Gate (European Commission) recall data. Each recall covers vehicles sold in that market; models sold elsewhere may differ.

Back to the Tesla Model Y

Front suspension fasteners may loosen

Headlight low beams may be too bright

Missing safety features may reduce occupant protection

Certification label may be missing

Rearview camera image may be delayed

Reverse lamps may fail to illuminate

Battery contactors may fail

Reverse lights may fail to illuminate

Right front window may not auto-reverse as required

Horn may not sound

Seat back fasteners may be loose

Washer hose connector may block the nozzles

Rearview camera display may be lost

Steering assistance may be lost after stopping

Power steering assist may be lost

Computer circuit board may fail, disabling rearview camera

Tyre pressure warning may not persist

Tire pressure warning light may not stay on

Front seat recliner weld may fail

Hood latch may not detect an unlatched hood

Seat belt warning may fail to alert an unbelted driver

Pedestrian warning sounds may be muted

Brake warning lights may be too small

Rearview camera image may not display

Driver assistance controls may not prevent misuse

Forward camera may disable safety features

Battery disconnect may not isolate high voltage

Steering wheel fastener may be loose

Second-row seat back bolts may be loose

Driver assistance software may act unsafely at intersections

Front suspension fasteners may be loose

Taillights may intermittently fail to illuminate

Power window may exert excessive force

Camera views may be swapped

Infotainment computer may overheat

Audio system may become unavailable

Boombox sounds may obscure pedestrian warnings

External sounds may obscure pedestrian warning

Heat pump software may reduce defrosting

Seat belt warning chime may not sound

Rolling stop feature may skip stop signs

Front suspension lateral link bolts may be under-torqued

Suspension knuckles may fracture and separate links

Software error may activate automatic emergency braking

Front suspension fasteners may loosen

Front seat belt fasteners may be loose

Rear seat belt retractor fasteners may be loose

Brake caliper bolts may loosen

Front upper control arm bolts may loosen

Trailer brake lights may not illuminate